氟碳漆施工工藝方案

1、精品文檔氟碳漆施工方案氟碳金屬漆涂裝工藝一、流程圖  施工工藝描述一 分格線1、 分格縫設置、定位、分格縫的長度、寬度、深度以及橫豎方向按甲方要求進行。2、 分格縫的切割：根據分格進行切割，切割要橫平豎直。分格縫切割后，用鑿子剔平，并用水清洗縫內灰塵。3、 分格縫填充與修補:待批刮好粗膩?zhàn)雍?分次填充分格縫膩?zhàn)?要深淺均勻,每次填充補前要用砂紙打磨并用水潤濕分格縫,對缺腳等進行修補,做到棱角清楚。4、 用圓弧形管拉成半弧形，待氟碳面漆噴完后，用羊毛刷著色。二找平膩?zhàn)?、 用批刀在分割好的板塊上沿水平方向滿批一道膩?zhàn)?，用刮尺沿水平方向用力刮平，假設有凹陷，那么用膩?zhàn)犹畛涔纹健?、 待其

2、完全干后，再沿垂直方向滿批膩?zhàn)右坏?，然后用另一把刮尺沿垂直方向豎刮，假設有凹陷，那么用找平膩?zhàn)犹畛涔纹健?、 假設平整度仍達不到要求，重復上述步驟，直到滿足平整度要求為止。三細膩?zhàn)?、 將本品的甲乙組分拌和均勻要求再4小時內用完，必要時加適當清水調節粘度。2、 滿批細膩?zhàn)?-2遍，間隔的時間為4-6小時，每遍膩?zhàn)訉雍穸燃s為1-2mm。3、 枯燥后用180#-240#砂紙打磨膩?zhàn)油獗?。四滲透底漆:環氧底漆N5050C54201、 將環氧底漆N5050C5420按漆：固4：1重量比攪拌均勻后，再參加適量的稀釋劑調節施工粘度?？捎盟⑼?、滾涂、噴涂。2、 用噴槍吹干凈細膩?zhàn)油獗淼母m，開始刷涂環氧底漆

3、N5050C5420，先橫向刷涂一遍，再豎向刷一遍。3、 枯燥24小時，無需打磨。五光面膩?zhàn)?、 將光面膩?zhàn)影幢壤浔然旌暇鶆蚝?，開始批刮。2、 滿批光面膩?zhàn)右槐椋穸却蠹s為0.5mm。必要時可批刮第二遍光面膩?zhàn)樱栝g隔6小時。3、 施工光面膩?zhàn)有杩菰?4小時之后采用400#砂紙打磨平整。(六)氟碳專用底漆:氟碳中間漆U5800/C58001、 將氟碳中間漆U5800/C5800按漆:固12:1重量比攪拌均勻后，再參加適量的稀釋劑調節施工粘度。靜止5分鐘消泡、熟化?？捎盟⑼?、滾涂、噴涂。2、 調整噴槍的空氣流量、出油量和噴霧幅寬，用噴槍吹干凈基面的浮塵后，開始噴涂作業。3、 先橫向噴涂一遍，

4、再豎向噴涂一遍。注意噴涂圖形的搭接，即去槍和回槍的運行軌跡有三分之一的局部相互重疊。這樣重復1-2個過程?？諌簷C(jī)的壓力應的0.2Mpa-0.5Mpa之間。4、 底漆需至少枯燥24小時后，用400#-600#砂紙打磨完全平整光滑為止。(七)氟碳面漆:氟碳金屬漆F5801J/C58001、 將氟碳金屬漆F5801J/C5800按漆:固=15:1面漆、固化劑、稀釋劑按比例混合攪拌均勻后，靜止5分鐘消泡、熟化，用200目的過濾網過濾到噴槍壺內。2、 調整噴槍的空氣流量、出油量和噴霧幅寬，用噴槍吹干凈基面的浮塵后，開始噴涂作業。3、 先橫向噴涂一遍，后豎向噴涂一遍。注意噴槍圖形的搭接，即去槍和回槍的運行

5、軌跡有三分之一的局部相互重疊。這樣重復1-2個過程?？记绊氈?、 在易開裂的墻面，為了防止開裂，必須掛網。2、 找平膩?zhàn)佑霉纬吖蝺杀?，使平整度小?mm。必須嚴格做到。3、 膩?zhàn)右⒁獗ｐB(yǎng)和枯燥時間，否那么會引起水泡和開裂現象。4、 滲透底漆的漆膜不要噴涂太厚，以免影響枯燥時間。滲透底漆也可以滾涂。5、 光面膩?zhàn)硬灰淮闻翁?，可以添加慢干稀釋劑?lái)調節枯燥速度和粘度以便易于施工。6、 氟碳專用底漆的漆、固比例要掌握好，否那么影響枯燥速度。7、 面漆尤其金屬面漆要掌握好環境溫度和稀釋劑的調整，應用慢干稀釋劑來調整。8、 如要罩光,一定要掌握好漆固的配比比例,否那么會引起色差。9、 要注意好氟碳

6、漆整套體系中漆、固化劑和稀釋劑的配套。10、噴涂氟碳漆面漆時，要把架子拆掉，用吊籃噴涂作業。11、每個工地要配發一定的慢干稀釋劑VX-03，以便調整揮發速度。12、氟碳漆到達最正確效果需要養護7天，因?yàn)樗且粋€(gè)慢速交聯過程。 成都宇華建筑工程 2011-7-15 g an employment tribunal claimEmployment tribunals sort out disagreements between employers and employees.You may need to make a claim to an employment tribunal if:

7、3; you don't agree with the disciplinary action your employer has taken against you· your employer dismisses you and you think that you have been dismissed unfairly.For more information about dismissal and unfair dismissal, see Dismissal.You can make a claim to an employment tribunal,

8、even if you haven't appealed against the disciplinary action your employer has taken against you. However, if you win your case, the tribunal may reduce any compensation awarded to you as a result of your failure to appeal.Remember that in most cases you must make an application to an

9、employment tribunal within three months of the date when the event you are complaining about happened. If your application is received after this time limit, the tribunal will not usually accept it.If you are worried about how the time limits apply to you, take advice from one of the organisations l

10、isted under Further help.Employment tribunals are less formal than some other courts, but it is still a legal process and you will need to give evidence under an oath or affirmation.Most people find making a claim to an employment tribunal challenging. If you are thinking about making a claim t

11、o an employment tribunal, you should get help straight away from one of the organisations listed under Further help.If you are being represented by a solicitor at the tribunal, they may ask you to sign an agreement where you pay their fee out of your compensation if you win the case. This is kn

12、own as a damages-based agreement. In England and Wales, your solicitor can't charge you more than 35% of your compensation  if you win the case.If you are thinking about signing up for  a damages-based agreement, you should make sure you're clear about the terms of the agreeme

13、nt. It might be best to get advice from an experienced adviser, for example, at a Citizens Advice Bureau.  To find your nearest CAB, including those that give advice by e-mail, click on nearest CAB.For more information about making a claim to an employment tribunal, see Employment tri

14、bunals.The (lack of) air up there Watch mCayman Islands-based Webb, the head of Fifa's anti-racism taskforce, is in London for the Football Association's 150th anniversary celebrations and will attend City's Premier League match at Chelsea on Sunday."I am going to be at the match to

15、morrow and I have asked to meet Yaya Toure," he told BBC Sport."For me it's about how he felt and I would like to speak to him first to find out what his experience was."Uefa has opened disciplinary proceedings against CSKA for the "racist behaviour of their fans&qu

16、ot; during City's 2-1 win.Michel Platini, president of European football's governing body, has also ordered an immediate investigation into the referee's actions.CSKA said they were "surprised and disappointed" by Toure's complaint. In a statement the Russian side adde

17、d: "We found no racist insults from fans of CSKA."Age has reached the end of the beginning of a word. May be guilty in his seems to passing a lot of different life became the appearance of the same day; May be back in the past, to oneself the paranoid weird belief disillusionment, these da

18、ys, my mind has been very messy, in my mind constantly. Always feel oneself should go to do something, or write something. Twenty years of life trajectory deeply shallow, suddenly feel something, do it.一字開頭的年齡已經到了尾聲?；蛟S是愧疚于自己似乎把轉瞬即逝的很多個不同的日子過成了同一天的樣子；或許是追溯過去，對自己那些近乎偏執的怪異信念的醒悟，這些天以來，思緒一直很凌亂，在腦海中不斷糾纏?？?/p>

19、覺得自己自己似乎應該去做點什么，或者寫點什么。二十年的人生軌跡深深淺淺，突然就感覺到有些事情，非做不可了。The end of our life, and can meet many things really do?而窮盡我們的一生，又能遇到多少事情是真正地非做不可？During my childhood, think lucky money and new clothes are necessary for New Year, but as the advance of the age, will be more and more found that those things are o

20、ptional; Junior high school, thought to have a crush on just means that the real growth, but over the past three years later, his writing of alumni in peace, suddenly found that isn't really grow up, it seems is not so important; Then in high school, think don't want to give vent to out your

21、 inner voice can be in the high school children of the feelings in a period, but was eventually infarction when graduation party in the throat, later again stood on the pitch he has sweat profusely, looked at his thrown a basketball hoops, suddenly found himself has already can't remember his ap

22、pearance.童年時，覺得壓歲錢和新衣服是過年必備，但是隨著年齡的推進，會越來越發現，那些東西根本就可有可無；初中時，以為要有一場暗戀才意味著真正的成長，但三年過去后，自己心平氣和的寫同學錄的時候，突然就發現是不是真正的成長了，好似并沒有那么重要了；然后到了高中，覺得非要吐露出自己的心聲才能為高中生涯里的懵懂情愫劃上一個句點，但畢業晚會的時候最終還是被堵塞在了咽喉，后來再次站在他曾經揮汗如雨的球場，看著他投過籃球的球框時，突然間發現自己已經想不起他的容顏。Originally, this world, can produce a chemical reaction to an event,

23、 in addition to resolutely, have to do, and time.原來，這個世界上，對某個事件能產生化學反響的，除了非做不可的堅決，還有，時間。A person's time, your ideas are always special to clear. Want, want, line is clear, as if nothing could shake his. Also once seemed to be determined to do something, but more often is he backed out at last. D

24、islike his cowardice, finally found that there are a lot of love, there are a lot of miss, like shadow really have been doomed. Those who do, just green years oneself give oneself an arm injection, or is a self-righteous spiritual.一個人的時候，自己的想法總是特別地清晰。想要的，不想要的，界限明確，好似沒有什么可以撼動自己。也曾經好似已經下定了決心去做某件事，但更多的

25、時候是最后又打起了退堂鼓。嫌惡過自己的怯懦，最終卻發現有很多緣分，有很多錯過，好似冥冥之中真的已經注定。那些曾經所謂的非做不可，只是青蔥年華里自己給自己注射的一支強心劑，或者說，是自以為是的精神寄托罷了。At the moment, the sky is dark, the air is fresh factor after just rained. Suddenly thought of blue plaid shirt; Those were broken into various shapes of stationery; From the corner at the beginning

26、 of deep friendship; Have declared the end of the encounter that haven't start planning. Those years, those days of do, finally, like youth, will end in our life.此刻，天空是陰暗的，空氣里有著剛下過雨之后的清新因子。突然想到那件藍格子襯衫；那些被折成各種各樣形狀的信紙；那段從街角深巷伊始的友誼；還有那場還沒有開始就宣告了終結的邂逅方案那些年那些天的非做不可，終于和青春一樣，都將在我們的人生中謝幕。Baumgartner the

27、 disappointing news: Mission aborted. r plays an important role in this mission. Starting at the ground, conditions have to be very calm - winds less than 2 mph, with no precipitation or humidity and limited cloud cover. The balloon, with capsule attached, will move through the lower level of the at

28、mosphere (the troposphere) where our day-to-day weather lives. It will climb higher than the tip of Mount Everest (5.5 miles/8.85 kilometers), drifting even higher than the cruising altitude of commercial airliners (5.6 miles/9.17 kilometers) and into the stratosphere. As he crosses the boundary lay

29、er (called the tropopause),e can expect a lot of turbulence.The supersonic descent could happen as early as Sunda.The weatheThe balloon will slowly drift to the edge of space at 120,000 feet ( Then, I would assume, he will slowly step out onto something resembling an Olympic diving platform.Below, the Earth becomes the concrete bottom of a swimming pool that he wants to land on, but not too hard. Still, he'll be traveling fast, so despite the distance, it will not be like diving into the deep end of a pool. It will be like he is diving into the shallow end. Sk