NXP SSL1750 75W LED調光驅動方案

1、.NXP SSL1750 75W LED調光驅動方案關鍵詞：電源管理,LED驅動器, AC/DC轉換器, SMPSNXP 公司的SSL1750 是開關電源(SMPS)控制器,適合用于25W到250W LED驅動應用. SSL1750包括功率因素修正(PFC)控制器和反激控制器.通用輸入電壓70 V 到 276 V (AC),具有多種保護特性和片內起動電流源.主要用在室內LED照明和戶外LED照明如街燈,區域照明如停車場以及隧道照明.本文介紹SSL1750主要特性, 方框圖, 典型配置電路以及120V(AC) 75W TRIAC可調光LED驅動器電路圖,材料清單和230V (AC) 75W TR

2、IAC可調光LED驅動器電路圖和材料清單.The SSL1750 is a Switched Mode Power Supply (SMPS) controller IC, suitable for driving LED applications from 25 W up to 250 W. For LED power requirements below 25 W the SSL152x family and SSL1623PH are the best choice.The SSL1750 combines a controller for Power Factor Correction

3、 (PFC) and a flyback controller. Its high level of integration allows the design of a cost-effective LED power supply with a very low number of external components.The special built-in green functions provide high efficiency at all power levels. This applies to quasi-resonant operation at high power

4、 levels, quasi-resonant operation with valley skipping, as well as to reduced frequency operation at lower power levels. At low power levels, the PFC switches over to burst mode control to maintain high efficiency. In burst mode, soft-start and soft-stop functions are added to eliminate audible nois

5、e.During low power conditions, the flyback controller switches to frequency reduction mode and limits the peak current to 25 % of its maximum value. This will ensure high efficiency at low power while minimizing audible noise from the transformer.The proprietary high voltage BCD800 process makes dir

6、ect start-up possible from the rectified universal mains voltage in an effective and green way. A second low voltage Silicon On Insulator (SOI) IC is used for accurate, high speed protection functions and control.The SSL1750 enables highly efficient and reliable LED drivers with power requirements o

7、f up to 250 W to be designed easily and with the minimum number of external components.SSL1750主要特性:Distinctive featuresIntegrated PFC and flyback controllerUniversal mains supply operation (70 V to 276 V (AC)High level of integration resulting in a very low external component count and a costeffecti

8、ve designGreen featuresOn-chip start-up current sourcePFC green featuresValley/zero voltage switching for minimum switching losses (patented)Frequency limitation to reduce switching lossesBurst mode operation if a low load is detected at the flyback output (patented)Flyback green featuresValley swit

9、ching for minimum switching losses (patented)Frequency reduction with fixed minimum peak current at low power operation tomaintain high efficiency at low output power levelsProtection featuresSafe restart mode for system fault conditionsContinuous mode protection by means of demagnetization detectio

10、n for bothconverters (patented)Undervoltage protection (foldback during overload)Accurate OverVoltage Protection (OVP) for both converters (adjustable for flybackconverter)Open control loop protection for both convertersIC overtemperature protectionLow and adjustable OverCurrent Protection (OCP) tri

11、p level for both convertersSoft-(re)start for both convertersSoft-stop PFC to minimize audible noiseMains undervoltage protection / brownout protectionGeneral purpose input for latched protection, e.g. to be used for system OverTemperature Protection (OTP)SSL1750主要應用: Indoor LED applications (> 2

12、5 W): Spot lights Down lights Other SSL consumer/industrial fixtures Outdoor LED applications (> 25 W): Street lightingArea lighting (e.g. car parking)Tunnel lighting圖1.SSL1750方框圖電子元器件分銷商 ADI代理商圖2.SSL1750應用電路圖3.SSL1750典型配置電路UM10394:火線120V 75W TRIAC可調光LED驅動器This SSL1750 board is a 75 W, 1000 mA cu

13、rrent regulated, LED driver that is dimmable with standard mains triac dimmers. The board is using the NXP SSL1750 switched mode power supply with integrated power factor correction (PFC) and a flyback controller. The circuitry for communication between both controllers is integrated and needs no ad

14、justment. The PFC output power is on-time controlled for simplicity. It is not necessary to sense the phase of the mains voltage. The flyback output-power is current-mode controlled for good suppression of input-voltage ripple.The board is very efficient, higher than 85 %, has a high power factor, a

15、bove 0.95 over the whole voltage input range and the THD falls within the limits for class-C equipment.Making this board ideal for dimmable high power LED lighting systems.The board has been optimized for triac-based dimmers. As different triac dimmers have different specifications the dimming performance of the reference board might vary based on the used dimmer. Transistor dimmers and other non-triac dimmers are not tested with this board.圖4. 75W TRIAC可調光LED驅動器板外形圖圖5.SSL1750T簡化功能應用框圖圖6. TRIAC相位檢測器 圖7.120V(AC)/60Hz 75W TRIAC調光LED驅