射孔彈類——安全數(shù)據(jù)表

1、southern sichuan machinery plant.casc material safety data sheet product identification product name shaped chargestrade names and synonyms shaped chargesmanufacturer/distributor southern sichuan machinery plantemergency number tel: (86)prevention of accidents in the use of explosives

2、the prevention of accidents in the use of explosives is a result of careful planning and observance of the best known practices. the explosives user must remember that he is dealing with a powerful force and that various devices and methods have been developed to assist him in directing this force.

3、he should realize that this force, if misdirected, may either kill or injure both him and his fellow workers. warning all explosives are dangerous and must be carefully handled and used following approved safety procedures either by or under the direction of competent, experienced persons in accorda

4、nce with all applicable federal, state, and local laws, regulations, or ordinances. if you have any questions or doubts as to how to use any explosive product, do not use it before consulting with your supervisor, or the manufacturer, if you do not have a supervisor. if your supervisor has any quest

5、ions or doubts, he should consult the manufacturer before use. hazardous componentsmaterial or componentcas no.tlvpelrdx00121-82-41.5 mg/m31.5 mg/m3hmx026914-41-0nenehns20062-22-0nenepyx38082-89-2nenedesensitizing waxn/anenealuminum07429-90-55 mg/m310mg/m3corrosion resistant steeln/aneneiron07439-89

6、-65 mg/m310 mg/m3graphite07782-42-515moocf(twa)2.5mg/m3copper07440-50-81 mg/m31 mg/m3lead07439-92-10.15 mg/m350 ug/m3tungsten07440-33-75 mg/m35 mg/m3zinc07440-66-6nenen/a = not assigned ne = not establish physical data explosive shaped charges contained in metal cases. hazardous reactivity instabili

7、ty detonates with friction, impact, heat or electrical current. incompatibility acids and alkalis hazardous decomposition detonation produces hazardous fragments. gases produced may contain carbon monoxide and nitrogen oxides. polymerization polymerization will not occur. fire and explosion data fla

8、shpoint not applicable extinguishing media none special fire fighting procedures all explosives: do not fight explosives fires. try to keep fire from reaching explosives. isolate area. guard against intruders. division 1.1 explosives: evacuate the area for 5000 feet (1 mile). in north america, consu

9、lt guide 112 of the north american emergency response guidebook for further detailsdivision 1.4 explosives: evacuate the area for 1500 feet (1/3 mile). in north america, consult guide 114 of the north american emergency response guidebook for further detailsunusual fire and explosion hazards may det

10、onate with impact or on heating. health hazards general shaped charges do not present health hazards in normal handling and use; however, the products are division 1.4 explosives, and detonation may cause severe physical injury, including death. all explosives are dangerous and must be handled caref

11、ully and used following approved safety procedures under the direction of competent, experienced persons in accordance with all applicable federal, state, and local laws, regulations, and ordinances. inhalation of explosives powders may cause nervous system irregularities including headaches and diz

12、ziness. nitrogen oxides generated during use are skin, eye, and respiratory tract irritants. carcinogenicity none of the components of shaped charges are listed as a carcinogen by ntp, iarc, or osha. first aid inhalation not likely route of exposure. if inhaled, remove to fresh air. if not breathing

13、, give artificial respiration, preferably by mouth-to-mouth. if breathing is difficult, give oxygen. seek prompt medical attention. eye and skin contact not a likely route of exposure. ingestion not a likely route of exposure. injury from detonation seek prompt medical attention. spill or leak proce

14、dures inhalation use appropriate personal protective equipment. isolate area and remove sources of friction, impact, heat, low level electrical current, electrostatic or rf energy. only competent, experienced persons should be involved in cleanup procedures. sweep up with non-sparking tools and remo

15、ve. waste disposal dispose of in compliance with federal regulations under the authority of the resource conservation and recovery act (40 cfr parts 260-271) special protection information ventilation use only with adequate ventilation. respiratory niosh approved particle masks for dust and midst. e

16、ye safety glasses or goggles. gloves impervious rubber gloves. other cotton overalls, undergarments, and socks. conductive soled shoes. special precautions keep away from friction, impact, and heat. do not consume food, drink, or tobacco in areas where they may become contaminated with these materia

17、ls. storage conditions store in accordance with the requirements：regulation for package, storage and transportion of pyrotechnics (gjb2001-1994). shipping information proper shipping nameshaped chargeshazard class 1.1d 1.4d 1.4s un number un0059 un0440un0441 the information contained in this materia

18、l safety data sheet is based upon available data and believed to be correct; however, as such has been obtained from various sources, including the manufacturer and independent laboratories, it is given without warranty or representation that it is complete, accurate, and can be relied upon. southern sichuan machinery plant has not attempted to conceal in any manner the deleterious aspects of the product listed herein, but makes no warranty as to such. further, southern sichuan machinery plant cannot anticipate nor control the many situations in wh