化妝品GMPC審核報告--CAR

1、Corrective Action RequestCAR 1 of 5匚 Major 匚 MinorOrganization:公司名稱:Guangzhou Yuerong Cosmetic Co., Ltd.Site(s) audited:審核地址：No.188, Chentai Road, YongxingVillage, Longgui, Taihe Town, Baiyun District,Guangzhou, Guangdong,P.R.ChinaDate(s) of audit(s):審核日期：2I23Auditor(s):審核員:Victor Chen; Henter Huang

2、Standard(s):標準：US-FDA CGMPOrganization Representative:Mr.LiangArea / Department / Process:生產Document Ref.:參考文件：GZYR02-M04-001-A0Standard Ref.:標準條款:FDA GMPc 條款 1Issue/Rev. Status:版本狀態：A0CAR Close out date:Next VisitDetails of Non-Conformity: 不符合的詳細描述：基礎設施管理維護不足，如：1 .潔凈車間內半成品存貯間 1-2樓板有一個空調孔洞；2.潔凈車間風淋室

3、入口感應系統不 能準確控制門禁開合；以上違反FDA CGMP條款1的要求。Premises management is insufficient, e.g. leaving a air-condition hole on floor of semi-finished products storage room , and the air shower s entries door control system is out of accurancy . Above against the clause 1 of FDA CGMP requirement.Organization Represe

4、ntative: 公司彳表：Mr.LiangAuditor:審核員：Victor Chen; Henter HuangAction taken to eliminate the detected nonconformity: 針對不符合的糾正：Corrective Action taken to prevent recurrence:避免同樣問題再發生的糾正措施：糾正措施：通知設備部人員3日內對空調孔洞進行修補，1 5日內完成對風淋間入口感應的調整。預防措施：針對以上硬件不合格項，進行一次硬件全面排查，找出存在隱患的硬件設施并予以糾正Organization Representative:Da

5、te:日期:公司彳表：Acceptance of Actions / Comments (use additional sheets if nMessa。接納糾正行動 /評論評論(如有必要時使用附頁):Auditor conclusion: NC is 匚I Maintained -匚I Downgraded to :- Closed審核員判定：不符合項二I保持-降級為：-口關閉Auditor:審核員Date:日期Response required (in months)回復要求(月數)PMajor嚴重Minor輕微Corrective Action must be addressed wit

6、hin time frame stated. Verification of actionwill occur at next visit. Additional follow up may be required as indicated.糾正行動必須于時限完成。將于下次拜訪時驗證該行動的果效。按顯示進行附加跟進。Define 確Close Out3Define 確認Close Out關閉1 month1個月3 months3個月5 days5天Next visit下次審核Corrective Action RequestCAR 2 of 匚 Major 匚 MinorOrganizatio

7、n:公司名稱:Guangzhou Yuerong Cosmetic Co., Ltd.Site(s) audited: 審核地址：No.188, Chentai Road, YongxingVillage, Longgui, Taihe Town, Baiyun District,Guangzhou, Guangdong,P.R.ChinaDate(s) of audit(s):審核日期：1Auditor(s):審核員:Victor Chen; Henter HuangStandard(s):標準：US-FDA CGMPOrganization Representative:Mr.LiangA

8、rea / Department / Process:生產 /ProductionDocument Ref.: 參考文件:GZYR02-M04-006-A0Standard Ref.:標準條款:5.cIssue/Rev. Status:版本狀態：A0CAR Close out date:Next VisitDetails of Non-Conformity: 不符合的詳細描述：生產現場使用的分裝消毒液和消毒液存貯桶沒有明確標識；生產設備清潔消毒管理制度文件編號GZYR-06-M06-012-A0 ,沒有規定使用的清洗劑及消毒劑品種；以上違反 FDA C GMPc條款5.c的要求。Bulk di

9、sinfectant and storged disfectants are not labeled. The usage category of detergent and disinfectant is not specified in EQUIPMENT CLEANING AND DISINFECTANT INSTRUCTION No. GZYR-06-M06-012-A0. Above against the clause 5.c of FDA CGMP requirement.Organization Representative:公司彳表：Mr.LiangAuditor:審核員：V

10、ictor Chen; HenterHuangAction taken to eliminate the detected nonconformity: 針對不符合的糾正：Corrective Action taken to prevent recurrence:避免同樣問題再發生的糾正措施：糾正措施：重新修訂GZYR-0 6 -M0 6 - 1 2 - A 0的管理制度文件，并按要求對現場的消毒液進行分類品種進行標識。預防措施：對操作現場的標識重新進行檢查，并明確相關的管理制度文件及SOP中所使用消毒液的種類及 用法。Organization Representative:Date:日期:公

11、司彳表：Acceptance of Actions / Comments (use additional sheets if necessary)接納糾正行動 /評論評論(如有必要時使用附頁):Auditor conclusion: NC is 匚I Maintained -匚I Downgraded to :- Closed審核員判定：不符合項匚|保持-降級為：-口關閉Auditor:審核員Date:日期Response required (in months)回復要求(月數)Major嚴重Minor輕微Corrective Action must be addressed within t

12、ime frame stated. Verification of actionwill occur at next visit. Additional follow up may be required as indicated.糾正行動必須于時限完成。將于下次拜訪時驗證該行動的果效。按顯示進行附加跟進。Define 確 以Close Out旬Define 確認Close Out關閉1 mnnth I I mon LI I2 mnnthQ monTTT。今日35 days5天Next visit下次審核orrective Action RequestCAR 3 of 5| | Major m

13、 I Minor爰Organization:公司名稱：Guangzhou Yuerong Cosmetic Co., Ltd.Site(s) audited:審核地址：No.188, Chentai Road, YongxingVillage, Longgui, Taihe Town, Baiyun District,Guangzhou, Guangdong,P.R.ChinaDate(s) of audit(s):審核日期：1Auditor(s):審核員:Victor Chen; Henter HuangStandard(s):標準：US-FDA CGMPOrganization Repre

14、sentative:Mr.LiangArea / Department / Process:生產 /ProductionDocument Ref.: 參考文件:GZYR02-M04-017-A0Standard Ref.:標準條款:5.aIssue/Rev. Status:版本狀態：A0CAR Close out date:Next VisitDetails of Non-Conformity: 不符合的詳細描述：審核現場罐裝產品批 WS170701 大周轉桶，存在批產品污染風險；以 When final products lot No.WS1707 pour the residual pro

15、ducts of balanc risk. Above against the clause 5.a of因突發停電，清場時罐裝員工將用于平衡小包裝量的剩余產品直接倒回成品 、上違反FDA C GMPc條款5.a的要求。01is filling, the power cut incident happen in audit site. The filling staff ;e bottle into the bulk products bucket, maybe bulk products pollution FDA CGMP requirement.Organization Represen

16、tative: 公司彳表：Mr.LiangAuditor:審核員：Victor Chen;Henter HuangAction taken to eliminate the detected nonconformity:針對不符合的糾正：Corrective Action taken to prevent recurrence:避免同樣問題再發生的糾正措施：糾正措施：對較受污染的半成品料休進行重新檢測，待確定合格后再進行下工序生產；預防措施：由生產部組織相關人員進行清場制度的強化培訓，讓操作人員清晰地了解并貫徹清場制度。Organization Representative: 公司彳表：Dat

17、e:日期：Acceptance of Actions / Comments （use additional sheets if nessa相接納糾正行動 /評論評論（如有必要時使用附頁）：Auditor conclusion: NC is 匚1審核員判定：不符合項Maintained -1 1 Downgraded to :- Closed二1保持-匚1降級為：-關閉Auditor:審核員Date:日期Response required (in months)回復要求(月數)Major嚴重Minor輕微Corrective Action must be addressed within tim

18、e frame stated. Verification of actionwill occur at next visit. Additional follow up may be required as indicated.糾正行動必須于時限完成。將于下次拜訪時驗證該行動的果效。按顯示進行附加跟進。Define 確以Close Out皿Define確認Close Out關閉1 month3 months-3-45 days5天Next visit下次審核Corrective Action RequestCAR 4 0f 5Job / Cert. n : CAN15370 CN12/3093

19、0Visit Type:2013/7/2223Visit n : 2Document:GP6408Issue n。：1Page n:3 of 6匚 Major 匚 MinorOrganization:公司名稱:Guangzhou Yuerong Cosmetic Co., Ltd.Site(s) audited: 審核地址：No.188, Chentai Road, YongxingVillage, Longgui, Taihe Town, Baiyun District,Guangzhou, Guangdong,P.R.ChinaDate(s) of audit(s):審核日期：Audito

20、r(s):審核員:Victor Chen; Henter HuangStandard(s):標準：US-FDA CGMPOrganization Representative:Mr.LiangArea / Department / Process:生產 /ProductionDocument Ref.: 參考文件:GZYR10-M00-001-A0Standard Ref.:標準條款:5Issue/Rev. Status:版本狀態：A0CAR Close out date:Next VisitDetails of Non-Conformity: 不符合的詳細描述生產現場蟲害控制管理不足GMPc

21、條款5的要求。；1）配料間沒有打開滅蚊燈2）成品倉一個門窗無法完全關閉。以上違反FDA CPest control management is insufficient on production site. E.g. the mosquito killer lamp being not turned on at weighing room, one window door can t be closed hemetically at warehouse. Above against the clause 5 of FDA CGMP requirement.Organization Repre

22、sentative: 公司彳表：Mr.LiangAuditor:審核員：Victor Chen; Henter HuangAction taken to eliminate the detected nonconformity: 針對不符合的糾正：Corrective Action taken to prevent recurrence:避免同樣問題再發生的糾正措施：糾正措施：對怕滅蚊燈重新打開使用，門窗通知設備部在3日內進行檢修；預防措施：1 .對現場操作及監督人員進行質量衛生和產品安全方面的培訓；2.對生產、倉儲及相關部門的滅蚊設施進行一次排查，并糾正已發現的不合格項。Organizati

23、on Representative:Date:日期:公司彳表：Acceptance of Actions / Comments (use additional sheets if necessary)接納糾正行動 /評論評論(如有必要時使用附頁):Auditor conclusion: NC is Maintained -Q Downgraded to :- Closed審核員判定：不符合項口 保持-降級為：-匚|關閉Auditor:審核員Date:日期Response required (in months) 回復要求(月數)Major嚴重Minor輕微Corrective Action m

24、ust be addressed within time frame stated. Verification of actionwill occur at next visit. Additional follow up may be required as indicated.糾正行動必須于時限完成。將于下次拜訪時驗證該行動的果效。按顯示進行附加跟進。Define 確林Close Out玨Define 確認Close Out關閉1 month3 months3不日5 days5天Next visit下次審核Corrective Action RequestCAR 5 of 5Job / C

25、ert. n : CAN15370 CN12/30930Visit Type:SurveillanceVisit n : 2Document:GP6408Issue n。：1Page n:4 of 6Organization:公司名稱：Guangzhou Yuerong Cosmetic Co., Ltd.Site(s) audited:審核地址：No.188, Chentai Road, YongxingVillage, Longgui, Taihe Town, Baiyun District,Guangzhou, Guangdong,P.R.ChinaDate(s) of audit(s)

26、:審核日期：Auditor(s):審核員:Victor Chen; Henter HuangStandard(s):標準：US-FDA CGMPOrganization Representative:Mr.LiangArea / Department / Process:生產 /ProductionDocument Ref.: 參考文件:GZYR10-M00-001-A0Standard Ref.:標準條款:1.eIssue/Rev. Status:版本狀態：A0CAR Close out date:Next VisitDetails of Non-Conformity: 不符合的詳細描述：外

27、包裝車間員工沒有專用洗手、消毒設施，以上違反FDA C GMPc條款1.e的要求。There is no specified wahing and disinfecting facility for outer packing workers in workshop.Above againstthe clause 1.e of FDA CGMP requirement.Organization Representative:Mr.LiangAuditor:審核員：Victor Chen; Henter公司彳表：HuangAction taken to eliminate the detected nonconformity:針對不符合的糾正：Correc