玩具專業英語

1、玩具方面（英語）問題描述噴油問題Painting defect雜聲Abnormal sound擦花Abrasion mark擦花痕Abrasion mark on玻璃紙擦花Abrasion mark on window sheet氣泡Air bubble on plating漆上有氣泡Air-bubble on painting混合裝Assortment park長毛脫落露底Bald spot on plush電池彈簧松Battery spring loosen電池彈簧甩Battery spring come off電池彈簧凸岀Battery spring expose接縫口打開了Beam o

2、pened豆袋公仔Bean bag toy屈曲Bent硅油Bilicon oil兩種語言裝Bilingual pack吸塑Blister吸塑咭Blister card吸塑咭爛Blister card damage吸紙內層內離Blister card delamination吸塑咭蒙Blister card illegible吸塑咭剪裁不良Blister card poor die-cut卡紙印刷不良Blister card poor printing吸塑卡上下倒轉熱燙Blister card sealed up-side down吸塑咭濕Blister card wet吸塑咭皺Blister

3、card wrinkle吸塑咭剪裁錯誤Blister card wrong die-cut吸塑裂Blister crack吸塑壓凹Blister crushed吸塑變形Blister deform吸塑甩掉Blister detach吸塑走位Blister misdirection吸塑裝Blister park吸塑不良Blister poor heat sealing外殼Housing底殼Housing bottom halve外殼等份Housing halves間竭無功能Iintermittent non-function塑料不純Impure plastic移印不完整/缺油Incomplete

4、 tampo painting吸塑不對Incorrect blister吸塑咭不對Incorrect blister card錯啤件顏色I(xiàn)ncorrect molding color包裝方法錯Incorrect packing method錯包裝比例Incorrect packing ratio噴油顏色不正確Incorrect paint color錯噴油方向Incorrect painting position膠袋不對Incorrect polybag移印油顏色不正確Incorrect tampo printing color移印圖按錯方向Incorrect tampo printing o

5、riention.移印圖按錯位置Incorrect tampo printing position.內罩厚度不正確Incorrect thickness of inner blister內罩破裂Inner blister cracked內罩壓環Inner blister crushed內罩破爛Inner blister damaged內箱Inner carton內托Insert內卡/托座破裂Insert card/platform break內卡/托座壓壞Insert card /platform crushed內卡/托座破爛Insert card/plateform damaged說明書In

6、struction sheet說明書蒙Instruction sheet illegible間竭功能Intermittent(int)-function掛j-hook掛爛j-hook bamage掛內層分離j-hook delamination掛剪裁不良j-hook poor die-cut掛膠貼移位j-hook sticker dislocate掛貼紙凸起j-hook sticker expose玩具方面（英語）問題描述吸塑縮水Blister shrinkage掛破j-hook wrinkle吸塑走料不到Blister undershot掛剪裁錯誤j-hook wrong die-cut吸塑

7、無粘Blister unseal跳針Jumping stitches脆Brittleness膠貼翹起Label peel off爛Broken力架積聚Lacquer accumulation噴油表面起泡Bubble paint左邊外殼Left housing halve膠袋裝Bulk pack燈泡無光Light bulb without light燒焦Burn mark車牌Linoege-plate吸塑燒焦Burn mark on blister公司嘜頭Logo吸塑咭燒焦Burn mark on blister card嘜頭不清楚Logo illegible蝴蝶孔爛Butterfly hook

8、 damage長線Long loose thread蝴蝶孔內層分離Butterfly hook decompose車縫太疏Low dense stitch蝴蝶孔剪裁不良Butterfly hook poor die-cut郵寄盒Mailer box蝴蝶孔剪裁錯誤Butterfly hook poor wrong die-cut其中某一功能不良Mal-function蝴蝶子孔破Butterfly hook wrinkle物料散口Materials fray鐵線扎帶Cable tie物料走紗Materials run脫落Come off卡紙甩色在車上Migration from card onto

9、 car不能旋轉Cannot rotate卡紙甩色在公仔身上Migration from card onto figure箱印蒙Carton mark illegible卡紙甩色在玩具身上Migration from card onto toy鉗痕Clamp mark配合錯誤Mismatch冷紋Cold mark放不正確Misarrange車軸冷打頭Cold-heading起級Mismatched parts顏色有差異Color deviation漏附件Missing component磨擦甩色Color migration漏產地來源Missing country of original顏色不

10、對稱Color misalignment漏日期印Missing date code顏色不配對Color mismatch漏嘜頭Missing logo顏色不配合Color mismatched漏車骨Missing marrowing電池片甩Contact plate come off漏噴油Missing paint電池片外露Contact plate expose漏裝配件Missing parts電池片松Contact plate loosen漏電鍍Missing plating電池片生銹Contact plate rust漏膠盒膠紙Missing sealing tape混點Contamin

11、ation漏移印Missing tampo printing混色Contamination mark漏整包配件Missing whole pack of accessory裂Crack漏玻璃紙Missing window sheet破裂Cracked氣煉問題Molding condition削痕Cut mark斑點Mottle油料深色Dark paint混點Mottle mark日期印蒙Date code illegible無聲No sound變形Deformation油漬Oil mark水口料Degraded material橙皮油Orange peel凹痕Dent mark漏噴油Orang

12、e peel painting彩盒膠窗有凹痕Dent mark on window box film公仔衫褪色Outfit fade污漬Dirty mark公仔衫縮水Outfit shrivel變色Discoloration公仔衫不合身Outfit unfit走位Dislocated公仔衫濕Outfit wet開口彩盒裝Display box park膠水多Over glue顏色染沉Dull color熱熨過多Over hot stamp啞色Dull painting電鍍過多Over plating漆上有塵Dust on painting印油過多Over print噴油有塵點Dust pain

13、t噴油過多Over spray噴油表面粘塵Dust painting熱燙過多Over stamp頂針位Ejector mark入棉過多Over stuffing漏電Electric leakage移印油過多Over tampo電子玩具Electronic toy氧化Oxidation電鍍擦花Electro-plating abraded包裝問題Packing defect電度擦花Electro-plating abrase abrade包裝方法Packing method電度發黑Electro-plating black mark混裝Packing ratio電度脫落Electro-plati

14、ng peel off噴油擦花Paint abraded電鍍成彩虹印Electro-plating rain聚油Paint accumulation電鍍陰陽色Electro-plating shadow噴油顏色有差別Paint color deviation電鍍變黃Electro-plating yellow噴油顏色亞色Paint color dull(matte)頂針痕Evection pin mark噴油顏色不對稱Paint color misalignment多余的批鋒Excessive burr噴油顏色不配對Paint color mismatch披鋒Excessive flash噴油

15、顏色有光澤Paint color shine(glossy)咀印花不良Poor em on mouth噴油反底（看到底色）Paint insufficient coverage臉太胖Face is too fat甩油/起皮Paint peel off蝴蝶結釘不良Poor tacking on bow -eie油污（染雜）Paint smear(dirty)纖維散口Fabric fray油漆太薄Paint under coverage布料組織不對Fabric texture mismatch涂油（油色）Painting夾口工具Fixture油漆顏色有差異Painting color deviat

16、ed蓋口打開Flap opened油漆顏色不配合Painting color mismatched植毛Flock油漆太厚Mainting oversprayed流水紋Flow lime油漆圖按不對稱Painting pattern misalignment流水痕Flow mark油漆脫落Painting peeled off折紋Fold line油漆刮花Painting scratched折痕Fold mark油漆被弄臟Painting smeared吸塑折痕Fold mark on blister card噴漆Painting spraying defects description彩盒折痕

17、Fold mark on gift box噴油不足Painting undersprayed折位破裂Folding line cracked夾摸線Part line外來液體Foreign liquid夾摸線移位Part line misalignment外來雜物Foreign materials膠件變形Parts deformed外來飛油Foreign paint膠件彎曲Parts warkpaged前殼Front housing halve沙梨皮（搪膠）Pear skin油箱蓋Fuel tank tip剝落Peel離穎Gap on長毛夾于縫口Pile trapped by seam水口Gat

18、e塑膠類Plastic水口未清Gate remnant on parts膠絲膠olaPlastic residue一般字眼General word斷鐵線Plastor wire broken彩盒壓爛/壓破Gift box crushed托座變形Plateform deformed彩盒壓變形Gift box deform電鍍氧化Plating oxided彩盒縫口爆開Gift box flap seam open電鍍層太薄Plating too thin彩盒蒙Gift box illegible毛公仔Plush彩盒裝Gift box pack膠袋爛/穿孔Polybag damage彩盒濕Gift

19、 box wet膠袋剪裁不良Polybag poor die-cut光面Glossy finishing膠袋縮水Polybag shrinkage光油Glossy painting膠袋走料不到Polybag undershot膠水霞?xì)釭lue gassing膠袋剪裁錯誤Polybag wrong die-cut膠水漬Glue mark外觀不良Poor aesthetic quality電鍍變黃Goldish plating裝配不良Poor assembly機油Grease mark油漆外層不良Poor coating冷卻水箱Grill氣壓鍋合不良Poor cold sticking配件裝不對稱

20、Hailers misalignment接觸不良Poor contact頭發剪裁不良Hair poor cut剪裁不良Poor cutting頭發夾于縫口Hair trapped by seam電鍍不良Poor electro-plating塑膠玩具Hard toy繡花不良Poor embroidery車縫太密Higt dense stitch噴油完成不良Poor finishing車頭蓋Hood搪膠植毛不良Poor flocking車軸熱熔頭Hot-deading功能不良Poor function燙金Hot-stamping發型不良Poor hair styling熱貼不良Poor heat

21、 sticking移印不完整Tampo incomplete溶合不良Poor hot melting移印移位Tampo off position熱燙/燙金不良Poor hot stamp移印位置不正確Tampo painting dislocate熨畫不良Poor hot stamping移印顏色不同Tampo painting mismatch車骨不良Poor marrowing移印套色偏移Tampo painting off set油漆涂噴不良Poor painting移印油顏色有差異Tampo printing color deviated電鍍不良Poor plating移油Tampo

22、printing defects description織毛不良Poor plushing移印套色晃良Tampo printing misregistrated印刷不良Poor printing移印圖按位置不對稱Tampo printing pattern misalignment彩盒印刷不良Poor printing of box移印刮花Tampo scratching補油不良Poor re-painting移印油弄臟Tampo printing smeared搪膠不良Poor rotacasting移印油太薄引致露底色Tampo printing too thin resulting ba

23、se visible車縫不良Poor sewing移印刮花Tampo scratching絲印不良Poor silk screen printing移印Tampo-printing釘縫形狀不良Poor sketching長線夾于縫口Thread trapped by seam噴油不良Poor spray太硬Too hard合縫不良Poor stitching太軟Too soft入棉形狀不良Poor stuffing頂殼Top housing halve移印不良Poor tampo printing玩具左右方向放錯Toy packed reversed direction透明度不良Poor tr

24、ansparency玩具反轉放在罩/盒內Toy parked w/back facing front玻璃紙透明度不好Poor transparency of window sheet變速箱Transmission gear-bos真空電鍍不良Poor vacuum plating打磨/修飾Trim彩盒破裂Printed box cracked膠水少Under glue彩盒套色不良Printing misregistration電鍍不足Under plating縫邊皺起Pucker印油不足Under print連花插R.C.A.plug.走料不足Under shot連花插座R.C A socke

25、t噴油過少Under spray電鍍有彩虹色Raimbowish plating熱熨不足Under stamp后殼Rear housing halve入棉不足Under stuffing后轆擋泥板Rear mud-guard移印油不足Under tampo后防撞桿Rear-bumper噴油不足，噴油起牙邊Under spray補油Re-paint膠件顏色不平均Uneven molding color絲帶散口Ribbon fray噴油不平均Uneven painting右邊外殼Right housing halve電鍍不平均Uneven plating姻脂Rough形狀不對稱Uneven sha

26、pe噴油表面不平滑Rough surface on coating噴油表面不均勻Uneven spray油漆面粗糙Rough surface painting入棉不平衡Uneven stuffing生銹Rust移印圖按不平均Uneven tampo printing刮花Scratch mark外罩厚薄不平均Uneven thickness of blister刮油Scratch paint內罩厚薄不平均Uneven thickness of inner blister刮花痕Scratched mark on搖模膠件厚度不平均Uneven wall thickness玻璃紙刮花Scratched

27、 mark on window sheet不修飾Untrim縫口子水外露Seam allowrance expose線未剪Untrimmed thread縫口爛開Seam open魔術貼甩Velcro detach嘜頭甩Sewing label loosen彎曲Warpage衣車靴痕Sewing machinery mark水印Water mark顏色光亮Shine color噴油水漬Water stain mark落貨箱Shipping carton夾水紋Weld mark箱嘜Shipping mark車輪不能轉Wheel stuck斷電路Short crcuit車轆芯W(wǎng)heel-hub走料

28、不足Shoutshot白盒White box膠片帶Shrink wrap發白White mark縮水Shrinkage彩盒膠窗發白White mark on window box film凹鉺Sink mark掛整大包Whole pack細聲Small sound彩盒透明窗Window box film布公仔Soft toy彩盒窗膠爛Window box film damage獨立裝Solid pack彩盒膠窗甩Window box film detach溶劑印Solvent mark彩盒膠窗粘合不良Window box film poor sealing超聲Sonic彩盒窗透明度不良Wind

29、ow box film poor transpare大聲Sound too loud彩盒膠窗頂白Window box filme stress噴油Spraying有膠窗彩盒裝Window box pack噴油/涂油/移印類Spraying,painting,tampo擋風玻璃Windshield打窗釘Staking電線甩掉Wire detach吠盤Steering-wheel電線凸出Wire expose針孔Stitching hole電線焊接不良Wire poor welding故事書蒙Story book illegible卡紙漏“飛機”孔Without airplane hoke on

30、blister card頂白Stress mark卡紙丁開掛鉤Without J hole on blister card膠件有頂白痕Stress mark on part穿孔Woid玻璃紙有發白痕Stressed mark on window sheet裝配錯誤Wrong assembly入棉比例不稱Stuffing disproportion用錯外罩Wrong blister棉料外露Stuffing expose用錯卡紙Wrong blister card移印不清楚/蒙Tampo illegible用錯內罩Wrong inner blister水紋Flow mark / flow lime

31、縮水Shrinkage折紋Fold mark / fold lime走料不到Undershot發白White mark穿孔Void頂白Scress mark凹印Simk mark披鋒Excessive flask水口料Degraded material屈曲Bant噴油有塵點Dust pairt變曲Warp噴油過多Over sprary裂縫Crack噴油過少Under sprary爛（不完全）Broken噴油不良Poor sprary夾模線移位Pent lime misalignment甩油/起皮Paint peel off擦花（痕跡）（記號）Abrasion mark橙皮油Orange pee

32、l燒焦Barn mark刮油Scratch paint頂針白Ejector mark油污Paint smear入水口Gate噴油起泡Bubble paint膠絲Plastic residue磨油甩色Color migration水漬Water mark顏色甩色Color mismatch太硬Too hard顏色不對稱Color misalignment太軟Too soft顏色有差別Color deliation鉗痕Clamp mark顏色沉Dall color氣泡Air bubble顏色光亮Shine color搪膠不良Poor potocasting聚油Paint accumulation混

33、點Contamination mark噴油水漬Water stain mark污漬Dirt mark噴油表面不平滑Rough surface削痕Cut mark移印不良Poor tampo搪膠件厚度不均勻Uneven wau thickness移印過少Urdor tampo沙裂皮白點）Pear skin移印過多Over tampo膠料不純（混合）Lmpure mlastic移印移位Tampo off position顏色不對稱Color mismatch絲印/印刷不良Poor silk screen printing變形Deformed印油過多Oror print油漬Oil mark印油不足U

34、nder print膠水過多Over glue外來油污Cmtamination膠水太小Under glue用錯油Incorrect painting color溶合不良Poor hot mealtime噴油位置錯Mcorrect paintin position裝配不良Poor assembiy漏噴油Missing paint刮花Seratch mark油漆脫落Painting peel off熱壓不良Poor heat sticking噴油不均勻Uneven painting啞色Dull finishing移印油顏色不正確Mcorrect tampo printing color錯啤件顏色I(xiàn)

35、ncorrect molding color移印圖案錯位置Mcorrect tampo printing plsition噴油及移印Spraying & tampo paicting移印套色不良Tampo printin misregistrated油漆涂噴不良Poor painting / poor coating移印油太薄引致露底色Tampo printing too thin resulting base visibl補油不良Poor re-painting熱熨及電鍍Hot stampelectro-plating油料深色Dark pairt熱熨不良Poor hot stamp電鍍不良P

36、oor electro-plating超聲Sonic welding電鍍變黃Electro-plating yeuowish超聲不良Poor sonic weld電鍍脫落Electro-plating pee/off超聲壓花Nest Mark電鍍擦花Electro-plating abrase配件不對稱Halves Misalignment電鍍成彩虹印Electro-plating rainbow離隙Gap on電鍍陰陽色Electro-plating shadow裝配部分及包裝Assembly DEPA packing ponk電鍍發黑Electro-plating black mark貼紙

37、翹起Label peel off電鍍氧化Electro-plating xidation熱封不良Poor Hot senling漏電鍍Missing electro-plating外來頭發Foreign human hair電鍍太薄Electro-plating too thin外來物料Foreign Materials電鍍不均勻Electro-plating unweven外來液體Foreign ciquid電子部分Electronich part油漬Dic / grease Mark雜聲Abnormal sound / Noisy sound牙松（齒輪）Gear loose電池彈簧凸岀Ba

38、ttery spring expose滑牙Gear smooth電池彈簧甩岀Battery spring come off不能移動Cannot more電池彈簧松Battery spring loosen不能轉動Cannot rotate接觸不良及焊接不良Poor contact soldering公仔手腳不能轉動Non -poseable無功能及功能不良Poor functional & Functional裝配不良Poor Assartmant ratio（INT ）間竭功能Intermittent functional混裝錯Wrong Assartmant Ratio大聲Sound to

39、o loud螺絲未上緊Scren unfasten小聲Sound too small螺絲甩Screw Came off無聲No sound螺絲生銹Screw Rust燈包無光Light bulb without light螺絲披鋒Screw plash電池片生銹Contact plate rust吸塑不良及不粘Blister poor Hent sealing unseal電池片外露Contact plate explse吸塑甩掉Blister Detach / come off電池片甩岀Contact plate come off吸塑變形Blister Deformation電池片松Cont

40、act plate loosen吸塑燒焦Burn Mark on Blister電線凸出Wime expose吸塑裂Blister crack電線甩掉Wime defach吸塑壓陷Blister crushecl電線焊接不良Wime poor welding吸塑有外來物料Exless material inside Blister短路Short circuit錯用吸塑罩Incorrect Blister used開關不良Poor switch吸塑不能站立Blister cannot stand無功能Non Function吸塑卡皺Blister card wrinkle間竭無功能INT Non

41、 -Function吸塑卡皺吸塑咭爛Blister card damage / broken電路板損壞Circuit Board Damage吸塑咭分離Blister card Delamination電路板無功能Circuit Board Non - Function標簽上下倒轉貼Label stich upside Down電路板松Circuit Board loosen旋鈕太緊Knob Too Tight開關無功能Switch Non -Function彩盒/外箱/說明書朦Gift box (carton mark/instrultion shect illegible)開關有INTSw

42、itch INT漏附件Missing port車縫及車梳SEWING OR ROOTING日期印Date code人棉形狀不良Pour stuffing彩盒膠窗粘合不良Window sheet pour sealed人棉不均勻Uneven Stuffing彩盒膠窗脫落Window sheet deta ched人棉比例不對稱Stuffing Disproportion彩盒膠窗劃花Scratch mark on window sheet of gift box縫戲不良Poor Stitching說明書錯Wrong Instruction sheet針孔Stitching包裝錯Wrong pack

43、aging跳針Jumping Stitching膠袋爛Polybag damage訂形狀不良Poor Sketching膠帶Adhesive剪裁不良Poor Sewing膠袋剪裁不良Polybag poor die -cut衣車化印Sewing machines boot mark膠袋/吸塑/吸塑咭不良Incorrect polybag / Blister / Blister card縫口爆開Sean openJ形掛勾爛/皺/內層分離J Hook Damage/ wrinkle / Delmination縫口子口外露Sean Anowanle exposeJ形掛勾膠貼凸起Hook sticker expose車骨不良Poor marroning彩盒未封口Giftbox unsealed漏車骨Missing marroning彩盒膠窗發白White mark on window sheet of