元器件降額標準(參考)

1、元器件降額準那么參考件元器件種類降額參數降額等級集成電路模擬電路放大器電源電壓0.700.800.80輸入電壓0.600.700.70輸出電流0.700.800.80功率0.700.750.80最高結溫8095105比擬器電源電壓0.700.800.80輸入電壓0.700.800.80輸出電流0.700.800.80功率0.700.750.80最高結溫8095105電 壓調整器電源電壓0.700.800.80輸入電壓0.700.800.80輸出輸入電壓差0.700.800.85輸出電流0.700.750.80功率0.700.750.80最高結溫8095105模擬開關電源電壓0.700.800.

2、85輸入電壓0.800.850.90輸出電流0.750.800.85功率0.700.750.80最高結溫8095105數字電路雙極型 電路頻率0.800.900.90輸出電流0.800.900.90最高結溫85100115MOS型電路電源電壓0.700.800.80輸出電流0.800.900.90功率0.800.800.90最高結溫85100115混和集成電路厚模集成電路W/cm27.5薄模集成電路W/cm26.5最高結溫85100115大規模集成電路最高結溫改良散熱方式降低結溫別離半導體器件晶體管方向電壓一般晶體管0.600.700.80功率MOSFET的柵源電壓0.500.600.70電流

3、0.600.700.80功率0.500.650.75功率管平安工作區集電極發射極電壓0.700.800.90集電極最大允許電流0.600.700.80最高結溫Tjm200115140160175100125145150Tjm-65Tjm-40Tjm-20微波晶體管最高結溫同晶體管二極管基準管除外電壓不適用于穩壓管0.600.700.80電流0.500.650.80功率0.500.650.80最高結溫Tjm200115140160175100125145150Tjm-65Tjm-40Tjm-20微波二極管最高結溫同二極管基準二極管可控硅/半導體光電器件電壓0.600.700.80電流0.500.

4、650.80最高結溫Tjm200115140160175100125145150Tjm-65Tjm-40Tjm-20固定電阻器合成型電阻器電壓0.750.750.75功率0.500.600.70環境溫度按元件負荷特性曲線降額薄膜型電阻器電壓0.750.750.75功率0.500.600.70環境溫度按元件負荷特性曲線降額電阻網絡電壓0.750.750.75功率0.500.600.70環境溫度按元件負荷特性曲線降額線繞電阻電壓0.750.750.75功率精密型0.250.450.60功率型0.500.600.70環境溫度按元件負荷特性曲線降額電位器非線繞電位器電壓0.750.750.75功率合成

5、、薄膜微調0.300.450.60精密塑料型不采用0.500.50環境溫度按元件負荷特性曲線降額線繞電位器電壓0.750.750.75功率普通型0.300.450.50非密封功率型0.70微調線繞型0.300.450.50環境溫度按元件負荷特性曲線降額熱敏電阻器功率0.500.500.50最高環境溫度TAM-15TAM-15TAM-15電容器固定玻璃釉型直流工作電壓0.500.600.70最高額定環境溫度TAMTAM-10TAM-10TAM-10固定云母型直流工作電壓0.500.600.70最高額定環境溫度TAMTAM-10TAM-10TAM-10固定陶瓷型直流工作電壓0.500.600.70

6、最高額定環境溫度TAMTAM-10TAM-10TAM-10固定紙/塑料薄膜直流工作電壓0.500.600.70最高額定環境溫度TAMTAM-10TAM-10TAM-10電解電容器鋁電解直流工作電壓0.75最高額定環境溫度TAMTAM-20鉭電解直流工作電壓0.500.600.70最高額定環境溫度TAMTAM-20TAM-20TAM-20微調電容器直流工作電壓0.300.400.500.50最高額定環境溫度TAMTAM-10TAM-10TAM-10電感元件熱點溫度THS(簡寫T)T-4025T-2510T-150工作電流0.600.700.600.700.600.70瞬間電壓/電流0.90.90

7、.9介質耐壓0.50.60.50.60.50.6扼流圈工作電壓0.70.70.7繼電器連續觸點電流小功率負荷100mW不降額電阻負載0.500.750.90電容負載最大浪涌電流0.500.750.90電感負載電感額定電流的0.500.750.90電阻額定電流的0.350.400.75電機負載電機額定電流的0.500.750.90電阻額定電流的0.150.200.35燈絲負載燈泡額定電流的0.500.750.90電阻額定電流的0.070.080.100.30觸點功率用于舌簧水銀式0.400.500.70線圈吸合電壓最小維持電壓0.900.900.90最小線圈電壓1.101.101.10線圈釋放電

8、壓最大允許值1.101.101.10最小允許值0.900.900.90最高額定環境溫度TAMTAM-20TAM-20TAM-20振動極限0.600.600.60工作壽命循環次數0.50開關連續觸點電流小功率負荷100mW不降額電阻負載0.500.750.90電容負載電阻額定電流的0.500.750.90電感負載電感額定電流的0.500.750.90電阻額定電流的0.350.400.75電機負載電機額定電流的0.500.750.90電阻額定電流的0.150.200.35燈絲負載燈泡額定電流的0.500.750.90電阻額定電流的0.070.080.100.15觸點電壓0.400.500.70觸點

9、功率0.400.500.70連接器工作電壓0.500.700.80工作電流0.500.700.80最高接觸對額定溫度TMTM-40TM-20TM-15電機最高工作溫度T-40T-20T-15最低極限000軸承載荷額定值0.750.900.90燈泡白熾燈工作電壓如可行0.940.940.94氖/氬燈工作電壓如可行0.940.940.94電路斷路器電流阻性負載0.750.750.90容性負載0.750.750.90感性負載0.400.400.50電機負載0.200.200.35燈絲負載0.100.100.15最高額定環境溫度TAMTAM-20保險絲電流額定值0.5A0.450.50.450.50.

10、450.50.5A0.20.40.20.40.20.4T25時，增加降額1/0.0050.0050.005晶體最低溫度TL+10TL+10TL+10最高溫度TU-10TU-10TU-10微波管最高額定環境溫度TAM-20TAM-20TAM-20輸出功率0.800.800.80反射功率0.500.500.50占空比0.750.750.75聲外表波器件輸入功率f100MHz降低+10dBm輸入功率f100MHz降低+20dBm纖維光學器件光纖光源峰值光輸出功率0.50適用于ILD電流0.50適用于ILD結溫設法降低光纖探測器PIN反向壓降0.60結溫設法降低光纖與光纜溫度上限額定值20；下限額定值

11、+20張力光纖耐拉試驗的0.20光纜拉伸額定值的0.50彎曲半徑最小允許值的0.20核輻射按產品詳細標準降額或加固導線與電纜最大應用電壓最大絕緣電壓規定值的0.50最大應用電流A線規AVG30/28/26/24/22/20/18/16單根導線電流ISV1.3/1.8/2.5/3.3/4.5/6.5/9.2/13.0線規AVG14/12/10/8/6/4單根導線電流ISV17.0/23.0/33.0/44.0/60.0/81.0雙極型數字電路降額準那么降額參數降額等級電源電容容限±3±5見技術條件頻率0.800.900.95輸出電流0.800.900.90最高結溫C85100

12、115HP電壓降額標準器件型號正常狀態最差狀態電阻峰值電壓(%)功率 (%)溫度峰值電壓(%)功率 (%)溫度碳膜、金屬膜5050PCB的標準焊接溫度£ 85° C5080PCB的標準焊接溫度£ 100° C³ 100 Kohm£1/4 W1/2 W50505080³ 1 W40504080< 100 Kohm£1/4 W805080801/2 W805080801 W80608080³ 2 W80508060玻璃釉電阻7060壓敏電阻80508080不同功率下的峰值電壓：1/6 W-200150V

13、；1/4 W-250V；1/2 W-350 V；1W-350 V；2W-350V；3W-500 V；5W-500V器件型號Isteady (%)Im (%)Isteady (%)Im (%)NTC-電阻PTC-電阻8080電容V DC (%)V CP (%)V peak (%)I rms(%)I p-p (%)Temp (%)V DC (%)V CP (%)V peak (%)I rms(%)I p-p (%)Temp (%)薄膜電容8585PEMPE9085MPP858585Ceramic fixed陶瓷電容75809090Electrolytic(85° C, 2000 h)80

14、80856090959070Electrolytic(105° C, 2000 h)8080906090959070Component TypNormal CaseWorst CaseInductorsCore Temp (°C)Core Temp (%)Core Temp (°C)Core Temp (%)Choke Coil80TransformerSemiconductorsTj min. = 150°CNote: Tj to Tcase has to be calculated for verification in any caseDiodeV

15、rm (%)Io (%)I fsm (%)Tcase (°C)Vrm (%)Io (%)I fsm (%)Tcase (°C)90507090Zener DiodePd (%)Iz (%)IFM (%)Tcase (°C)Pd (%)Iz (%)IFM (%)Tcase (°C)50508090Damp/Modulation DiodeVrm (%)Io (%)I fsm (%)Tcase (°C)90507090TransistorsVce (%)Veb (%)IC (%)Tcase (°CVce (%)Veb (%)IC (%)Tcase (°C85858585858590MOSFETVpss (%)Ip (%)IDM (%)VGS (%)Vpss (%)Ip (%)IDM (%)VGS (%)8580808590858085ICVpeak (%)Pd (%)Tcase (°C)Vpeak (%)Pd (%)Tcase (°C)808090858090PCB ( Solder Temp)£ 85°C£ 100°CSpecial PartsVpeak (%)Irms (%)T