主發電機及主配電板試驗冊記錄表資料

1、REPORT OF INSPECTION REPORT OF INSPECTIONTABLES1userPage 19/30/2017 -2013124絕緣電阻測量記錄Insulation Resistance Measuring Record機組項目測量相位冷態 (M)熱態 (M )D/G setMeasuring ItemPhaseCold conditionHot conditionR發電機定子繞組SNO.1Stator winding of generatorT空間加熱器 Space heaterR發電機定子繞組NO.2Stator winding of generatorST空間加熱

2、器 Space heaterR發電機定子繞組SNO.3Stator winding of generatorT空間加熱器 Space heater檢驗員 :船東：船級社：QC：OWNER：CLASS：1REPORT OF INSPECTION REPORT OF INSPECTIONuser12名 稱MSB AC440 insulationMSB AC440V絕緣MSB AC220 insulationMSB AC220V絕緣monitoring -alarm circuit監測報警系統TABLES2Page 29/30/2017 -20234MSB絕緣檢查MSB insulation che

3、ck結 果Test Result（ M ）Check up insulation of monitoring -alarm circuit（Use multimeter） .檢查監視報警電路的絕緣( 使用萬用表 ) 。檢驗員 :船東：船級社：QC：OWNER：CLASS：2REPORT OF INSPECTION REPORT OF INSPECTIONTABLES3userPage 39/30/2017 -2033124開關型號和脫扣器編號試驗Main項目ACBTesttypeItemandNo.oftripper1#主開關No.1mainACB2#主開關No.2mainACB3#主開關No

4、.3mainACB檢驗員 :QC：主配電板保護報警試驗報告Test report of protection device of main switchboard欠壓保護Under逆功率保護過載保護Overload protectionVoltageReverse powerProtectprotectionion預報警長延時短延時PRE-ALARML.T. delayS.T. delay逆功延時電壓率時間延時電流延時時電流VoltageReverseTime電流時間時間Curr間 TimeCurr(V)power(sec)Curr.TimeTime.(KW)(A)(sec)(sec)(A)(

5、A)(sec)船東：船級社：OWNER：CLASS：3REPORT OF INSPECTION REPORT OF INSPECTIONTABLES4userPage 49/30/2017 -2043124主配電板聯鎖試驗Interlock Test of Main Switchboard1. 發電機主空氣斷路器與空間加熱器Generator ACB and Space heater名稱結果DescriptionTest Result1#發電機空間加熱器No.1 Generator Space heater2#發電機空間加熱器No.2 Generator Space heater3#發電機空間

6、加熱器No.3 Generator Space heater2. 發電機主空氣斷路器與岸電空氣斷路器Generator ACB and Shore power ACB名稱結果DescriptionTest Result1#發電機與岸電聯鎖Interlock between No.1 Generator and Shore Power2#發電機與岸電聯鎖Interlock between No.2 Generator and Shore Power3#發電機與岸電聯鎖Interlock between No.3 Generator and Shore Power檢驗員 :船東：船級社：QC：OW

7、NER：CLASS：4REPORT OF INSPECTION REPORT OF INSPECTIONTABLES5userPage 59/30/2017 -2053124操縱試驗Test of manual controlsD/G NO.1D/G NO.2D/G NO.3RemarksD/G LocalStartStart possibleS.W.起動可以起動機旁開關StopStart possible停止可以停止MSBStartStart possibleremote起動可以起動S.W.StopStart possible遙控開關停止可以停止檢驗員 :船東：船級社：QC：OWNER：CL

8、ASS：5REPORT OF INSPECTION REPORT OF INSPECTIONTABLES6userPage 69/30/2017 -2063124主柴油發電機組冷態起動試驗Main D/G set start test under cold condition1#柴油發電機組2#柴油發電機組3#柴油發電機組No.1 D/G setNo.2 D/G setNo.3 D/G set起動前氣壓起動后氣壓起動前氣壓起動后氣壓起動起動前氣壓起動Press.起動Pressure起動后氣壓Press.Pressure次數Pressure次數after次數afterPressure after

9、beforebeforestartbeforestartstartstartstartstartstartstarttimesstarttimesMPatimesMPaMPaMPaMPaMPa111222333檢驗員 :船東：船級社：QC：Ship Owner:CASS：6REPORT OF INSPECTION REPORT OF INSPECTIONTABLES7userPage 79/30/2017 -2073124No.1號柴油發電機組負荷試驗Load Test of No.1 D/G set機艙溫度 AIR TEMP. IN E/R:發電機負荷種類 KIND OF LOAD%0255

10、075100100110輸出功率 OUTPUT POWERKW運行時間 Duration of RunsMin.電壓 VoltageV電流 CurrentA頻率 FrequencyHz轉速 Speedrpm功率因數 Power Factorcos 高溫水進機溫度HT.water inlet Temp.高溫水出機溫度HT.water outlet Temp.高溫水進機壓力barHT.water inlet Press.低溫水空冷氣前溫度LT.water beforeAircoolerTemp.低溫水空冷氣前壓力barL.T.W. before Aircooler Press.滑油進濾器溫度L.O

11、.inlet filter Temp.滑油進濾器壓力barL.O.inlet filter Press.滑油進機壓力barL.O.inlet Press.滑油進增壓器壓力barL.O Press. (T/C inlet)燃油進口溫度F.O.inlet Temp.燃油進口壓力 F.O inlet Press.bar增壓器進氣溫度 TC inlet Temp.增壓器空氣壓力TC change air press.增壓器前溫度Before T/C Temp.增壓器后溫度After T/C Temp.1排氣溫度缸號2Exhaust Gas Cylinder3Temp.NO.45檢驗員 :船東：船級社：

12、QC：OWNER：CLASS：7REPORT OF INSPECTION REPORT OF INSPECTIONTABLES8userPage 89/30/2017 -2083124No.2號柴油發電機組負荷試驗Load Test of No.2 D/G set機艙溫度 AIR TEMP. IN E/R:發電機負荷種類 KIND OF LOAD%0255075100100110輸出功率 OUTPUT POWERKW運行時間 Duration of RunsMin.電壓 VoltageV電流 CurrentA頻率 FrequencyHz轉速 Speedrpm功率因數 Power Factorc

13、os 高溫水進機溫度HT.water inlet Temp.高溫水出機溫度HT.water outlet Temp.高溫水進機壓力barHT.water inlet Press.低溫水空冷氣前溫度LT.water beforeAircoolerTemp.低溫水空冷氣前壓力barL.T.W. before Aircooler Press.滑油進濾器溫度L.O.inlet filter Temp.滑油進濾器壓力barL.O.inlet filter Press.滑油進機壓力barL.O.inlet Press.滑油進增壓器壓力barL.O Press. (T/C inlet)燃油進口溫度F.O.i

14、nlet Temp.燃油進口壓力 F.O inlet Press.bar增壓器進氣溫度 TC inlet Temp.增壓器空氣壓力TC change air press.增壓器前溫度Before T/C Temp.增壓器后溫度After T/C Temp.1排氣溫度缸號2Exhaust Gas Cylinder3Temp.NO.45檢驗員 :船東：船級社：QC：OWNER：CLASS：8REPORT OF INSPECTION REPORT OF INSPECTIONTABLES9userPage 99/30/2017 -2091324No.3號柴油發電機組負荷試驗Load Test of N

15、o.3 D/G set機艙溫度 AIR TEMP. IN E/R:發電機負荷種類 KIND OF LOAD%0255075100100110輸出功率 OUTPUT POWERKW運行時間 Duration of RunsMin.電壓 VoltageV電流 CurrentA頻率 FrequencyHz轉速 Speedrpm功率因數 Power Factorcos 高溫水進機溫度HT.water inlet Temp.高溫水出機溫度HT.water outlet Temp.高溫水進機壓力barHT.water inlet Press.低溫水空冷氣前溫度LT.water beforeAircoole

16、r Temp.低溫水空冷氣前壓力LT.water before AircoolerbarPress.滑油進濾器溫度L.O.inlet filter Temp.滑油進濾器壓力barL.O.inlet filter Press.滑油進機壓力 L.O.inlet Press.bar滑油進增壓器壓力barL.O Press. (T/C inlet)燃油進口溫度 F.O.inlet Temp.燃油進口壓力 F.O inlet Press.bar增壓器進氣溫度 TC inlet Temp.增壓器空氣壓力TC change air press.增壓器前溫度 Before T/C Temp.增壓器后溫度 Af

17、ter T/C Temp.1排氣溫度缸號2Exhaust Gas Cylinder3Temp.NO.45檢驗員 :船東：船級社：QC：OWNER：CLASS：9REPORT OF INSPECTION REPORT OF INSPECTIONTABLES10userPage 109/30/2017 -20103124發電機靜態調壓特性試驗Generator characteristic test under static condition發電負荷輸出功率機組LoadOutputD/G%KWNo.17533010044075330502202511000251105022075330No.27

18、533010044075330502202511000251105022075330No.37533010044075330502202511000251105022075330電壓變化率Voltage variation:輸出電壓V電壓調整率頻率 Hz備注Output voltageVoltageFrequencyremarkCharacteriABCstic U2.5% (438.75V 461.25V)U=(U-Un)/Un100%， U2.5%檢驗員 :船東：船級社：QC：OWNER：CLASS：10REPORT OF INSPECTION REPORT OF INSPECTIONTA

19、BLES11userPage 119/30/2017 -20113124NO. 1 號發電機組調速器和瞬態調壓特性試驗No. 1 Generator Governor Test負荷變機號化 LOAD狀態電壓V頻率 Hz轉速 rmpD/G穩定時ConditionVoltageFrequencySpeed間 TIME變化前 before change瞬間 momentary穩定 steady100% 0%穩定時間 time (sec)瞬變率 momentary vari.穩變率 stable vari.變化前 before change瞬間 momentary穩定 steadyNo.10% 50%

20、穩定時間 time瞬變率 momentary vari.穩變率 stable vari.變化前 before change50%100%頻率變化率Frequencyvariation電壓變化率Voltagevariation瞬間 momentary穩定 steady穩定時間 time瞬變率 momentary vari.穩變率 stable vari.穩態負載頻率變化不超過5% (57Hz 63Hz),穩定時間不大于5 秒5% under stead y load condition within 5 sec (57Hz 63Hz)瞬態負載頻率變化不超過10% (54Hz 66Hz)10% u

21、nder transient load condition (54Hz 66Hz)穩態負載電壓變化-10%, +6% (405V 477V)-10%, +6% under the steady load condition (405V 477V)瞬態負載電壓變化不超過-15%, +20% (382.5V 540V)-15%, +20% under the transient load condition (382.5V 540V)檢驗員 :船東：船級社：QC：OWNER：CLASS：11REPORT OF INSPECTION REPORT OF INSPECTIONTABLES12userP

22、age 129/30/2017 -20123124NO. 2 號發電機組調速器和瞬態調壓特性試驗No. 2 Generator Governor Test機號D/GNo.2負荷變化 LOAD狀態電壓V頻率 Hz轉速 rmp穩定時ConditionVoltageFrequencySpeed間 TIME變化前 before change瞬間 momentary穩定 steady100% 0% 穩定時間 time (sec)瞬變率 momentary vari.穩變率 stable vari.變化前 before change瞬間 momentary穩定 steady0% 50%穩定時間 time瞬

23、變率 momentary vari.穩變率 stable vari.變化前 before change50%100%頻率變化率Frequencyvariation電壓變化率Voltage瞬間 momentary穩定 steady穩定時間 time瞬變率 momentary vari.穩變率 stable vari.穩態負載頻率變化不超過5% (57Hz 63Hz),穩定時間不大于5 秒5% under steady load condition within 5 sec (57Hz 63Hz)瞬態負載頻率變化不超過10% (54Hz 66Hz)10% under transient load

24、condition (54Hz 66Hz)穩態負載電壓變化-10%, +6% (405V 477V)-10%, +6% under the steady load condition (405V 477V)瞬態負載電壓變化不超過-15%, +20% (382.5V 540V)variation-15%, +20% under the transient load condition (382.5V 540V)檢驗員 :船東：船級社：QC：OWNER：CLASS：12REPORT OF INSPECTION REPORT OF INSPECTIONTABLES13userPage 139/30/

25、2017 -20133124機號D/GNo.3NO.3 號發電機組調速器和瞬態調壓特性試驗No.3 Generator Governor Test負荷變化 LOAD狀態電壓V頻率 Hz轉速 rmp穩定時ConditionVoltageFrequencySpeed間 TIME變化前 before change瞬間 momentary100% 0%穩定 steady穩定時間 time (sec)瞬變率 momentary vari.穩變率 stable vari.變化前 before change瞬間 momentary0% 50%穩定 steady穩定時間 time瞬變率 momentary v

26、ari.穩變率 stable vari.變化前 before change瞬間 momentary50%100% 穩定 steady穩定時間 time瞬變率 momentary vari.穩變率 stable vari.穩態負載頻率變化不超過 5%(57Hz 63Hz),穩定時間不大于 5 秒5% under steady load condition within 5 sec (57Hz 63Hz)頻率變化率Frequencyvariation電壓變化率Voltagevariation瞬態負載頻率變化不超過10% (54Hz 66Hz)10% under transient load con

27、dition (54Hz 66Hz)穩態負載電壓變化-10%, +6% (405V 477V)-10%, +6% under the steady load condition (405V 477V)瞬態負載電壓變化不超過-15%, +20% (382.5V 540V)-15%, +20% under the transient load condition (382.5V 540V)檢驗員 :船東：船級社：QC：OWNER：CLASS：13REPORT OF INSPECTION REPORT OF INSPECTIONTABLES14userPage 149/30/2017 -201431

28、24柴油發電機組并聯運行試驗報告(1/3 ）Test Report of Diesel Generators Parallel Running（1/3 ）1#和 2#發電機并聯運行試驗1# and 2# D/G set parallel running test負荷75%100%75%50%25%50%75%100%75%Load660KW880KW660KW440KW220KW440KW660KW880KW660KW試驗項目 Test item5min5min5min5min5min5min5min5min5min電壓 VoltageV頻率 Frequency Hz功率 PowerKW1#發

29、電機電流 Current1# D/GA功率因數Factor COS 功率 PowerKW2#發電機電流 Current2# D/GA功率因數Factor COS 2#和 3#發電機并聯運行試驗2# and 3# D/G set parallel running test75%負荷 Load75%100%75%50%25%50%75%100%660660KW880KW660KW440KW220KW440KW660KW880KWKW試驗項目 Test item5min5min5min5min5min5min5min5min5min電壓 VoltageV頻率 Frequency Hz功率 Power

30、KW2#發電機電流 Current2# D/GA功率因數Factor COS 功率 PowerKW3#發電機電流 Current3# D/GA功率因數Factor COS 檢驗員 :船東：船級社：QC：OWNER：CLASS：14REPORT OF INSPECTION REPORT OF INSPECTIONTABLES15userPage 159/30/2017 -20153124柴油發電機組并聯運行試驗報告 (2/3）Test Report of Diesel Generators Parallel Running（2/3）1#和 3#發電機并聯運行試驗1# and 3# D/G set

31、 parallel running test負荷 Load75%100%75%50%25%50%75%100%75%660KW880KW660KW440KW220KW440KW660KW880KW660KW試驗項目 Test item5min5min5min5min5min5min5min5min5min電壓 VoltageV頻率 FrequencyHz功率 PowerKW1#發電機電流 Current1# D/GA功率因數Factor COS 功率 PowerKW3#發電機電流 Current3# D/GA功率因數Factor COS 并聯運行發電機負荷相對于每臺電機額定功率的最大偏差應th

32、e divergence of each generator shall not exceed發電機有功功率分配: P= (P 實際 -P 平均 )/P H 100 =發電機無功功率分配: Q= (Q 實際 -Q 平均 )/Q H 100 =15%。 * 506KW (66KW)15% rated power of one generator.（ 15）（ 10）generator available power distribution: P= (P -P )/PH 100=（ 15）Pagenerator unavailable power distribution： Q=(Qp -Q a

33、)/Q H 100 =（ 10）檢驗員 :船東：船級社：QC：OWNER：CLASS：15REPORT OF INSPECTION REPORT OF INSPECTIONTABLES16userPage 169/30/2017 -20163124電站管理系統試驗（模式選擇自動） （1/3 ）Power manager system test for generator set(mode select“ aoto ”)1#機組2#機組3#機組條件 Condition試驗方法 Means of test功能 FunctionNo.1 D/GNo.2 D/GNo.3 D/GMSB匯流排無電按發電機

34、起動按鈕push第一備用發電機起動并合閘1 STstandby D/G can start and ACB壓 MSB dead bus“auto start button”close按備用發電機起動按鈕備用發電機起動并自動同步、并車一臺發電機在線Standby D/G can start andpush standby D/G“autoone D/G onlinsynchronizer and paralledstart butten ”running automaticlly模擬發電機起動故障下按第一備用不能起動，第二備用發電備用發電機起動按鈕機起動并自動同步合閘when 1 ST一臺發電機

35、在線simulate the start failstandby D/G can not start.2one D/G onlinNDof standby D/G and pushstandby will be started andthe “ auto start butten ”paralled running automaticlly延時 5S，備用發電機起動， 在線發模擬在線發電機故障報警電機掉閘，然后備用發電機合閘Standby D/G will be started一臺發電機在線Simulate the D/G faildelay 5s.then the ACB of D/Gone

36、 D/G onlinalarm onlineonline will be triped andstandby D/G will be closed.檢驗員 :船東：船級社：QC：OWNER：CLASS：16REPORT OF INSPECTION REPORT OF INSPECTIONTABLES17userPage 179/30/2017 -20173124電站管理系統試驗（模式選擇自動） （2/3 ）Power manager system test for generator set(mode select“ aoto ”)1#機組2#機組3#機組條件 Condition試驗方法 Me

37、ans of test功能 FunctionNo.1 D/GNo.2 D/GNo.3 D/G讓其負荷大于 85%Set up to第一備用發電機起動，同步、并車一臺發電機在線并平衡負荷 1 ST standby D/G willthe load larger than 85%one D/G onlinbe started then synchronizerandrate of D/G onlineparallel and transform load讓其負荷大于 85%，但第一備用發電機不能起動 Set up第二備用發電機起動，同步、并車一臺發電機在線to the load larger th

38、an并平衡負荷 2 ND standby D/G willone D/G onlin85%rate of D/G online andbe stared. Then synchronizerand1ST standby D/G can tparallel and transform load.start二臺發電機并聯第二備用發電機起動，同步、并車讓其總負荷大于 85% two并平衡負荷 2 ND standby D/G will運行 two D/GD/G parallel onlinbe stared. Then synchronizerandparallel onlinparallel an

39、d transform load.自動轉移負荷，其中一臺發電機掉二臺發電機并聯讓其負荷小于 35% Set up閘后停車運行 two D/Gto the load smaller thanThe ACB of D/G online trip thenparallel onlin35% rate of D/G onlineD/G stop after transform loadneither.自動轉移負荷，其中一臺發電機掉三臺發電機并聯讓其負荷小于 35% Set up閘后停車運行 three D/Gto the load smaller thanThe ACB of D/G online t

40、rip thenparallel onlin35% rate of D/G onlineD/G stop after transform loadthereinto.檢驗員 :船東：船級社：QC：OWNER：CLASS：17REPORT OF INSPECTION REPORT OF INSPECTIONTABLES18userPage 189/30/2017 -20183124電站管理系統試驗（模式選擇自動） （ 3/3 ）Power manager system test for generator set(mode select“aoto ”)條件 Condition試驗方法Means

41、of test在克令吊室按請求起動一臺發電機在線按鈕 push the requestone D/G onlinebutton in the deckcrane operation room二臺發電機在線功能 Function自動判斷剩余功率，如大于克令吊電機功率，給出允許起動信號。反之，則起動備用發電機，并車后再給出允許起動信號 compare the remaining power. If it so larger than motor power of the deck crane.sut up the allow start signal to it. Reverse. Itwill

42、start standby D/G and parallel online then do it.1#克令2#克3#克4#克吊令吊令吊令吊two D/G同上 ditto同上 dittoparallel online三臺發電機在線three D/G同上 ditto同上 dittoparallel online檢驗員 :船東：船級社：QC：OWNER：CLASS：18REPORT OF INSPECTION REPORT OF INSPECTIONTABLES19userPage 199/30/2017 -20193124自動卸載試驗Automatic be disconnected test f

43、or generator set.第一次過載扣脫第二次過載脫扣1STpreparation trip2ND preparation trip結果項目 Item延時時間延時時間電流Test Result電流 Current （ A）DelayCurrentDelaytime(sec)（ A）time(sec)1#發電機組1# D/G set2#發電機組2# D/G set3#發電機組3# D/G set說明：過載脫扣設定置為：90% （ 635.4A ），第一次過載扣脫延時時間為：10S，第二次過載扣脫延時時間為： 15S。Note: overload preparation trip set: 90%（ 635.4A ）, 1 ST preparation trip delay time:10S, 2NDpreparation trip delay time:15S.第一次過載扣脫：中央空調、絞盤、廚