皮革抗菌劑,抗菌防臭整理劑,衣料抗菌加工劑,防霉防腐劑,紡織

1、棉織物由于價廉物美、吸濕性好、穿著舒適等優點而倍受人們喜 愛，但是棉織物對微生物低劣的抵抗性使其廣泛應用遇到一定的挑戰。 隨著人們生活水平的提離和健康環保意識的增強，對紡織品衛生保健 功能的要求越來越高，因此對棉織物進行抗菌整理具有十分垂要的意 義。在各種抗菌劑中，納米氧化鋅的抗菌效果非常好，還具有廣譜抗 菌、高效持久、對人體無毒無刺激等優點，因此本論文主要研究了納 米氧化鋅抗菌劑的制備并對棉織物進行抗菌整理使之獲得良好的抗菌 性能。由于納米材料的特殊效應，使得納米抗菌劑的性能遠比傳統抗菌 劑要優越。市售的納米抗菌劑產品多為粉末狀的，對織物進行抗菌整 理時必須先將其配成抗菌劑顆粒均勻分散的溶液

2、。前人己有的研究表 明，由于納米微粒之間吸附作用很強，非常容易發生團聚，使得抗菌 劑顆粒無法在織物上均勻分布，高溫焙烘后抗菊劑粉體又很容易從織 物上脫落，嚴重影響了織物的抗菌效果。針對這個問題，本課題基于 文獻綜述中無機抗菌劑的優點，選擇了 ZnO為無機抗菌劑.納米氧化 鋅的抗菌性能來源于光催化活性及金屬離子溶出機理，綜合比較了 ZnO 制備方法的優劣，再結合科研實際情況，本辣題選擇了 ZnCb、NaOII、 聚丙烯酸納(PAAS)、？ 一縮水甘油瞇氧丙基三甲氧基硅烷(GPTMS) 等為基本原料，采用了微乳法和溶膠一凝膠法配制了 ZnO溶膠，并用 XRD和Zetar激光粒度儀進行檢測和表征；在

3、不影響棉織物手感的前 提下，采用浸軋烘抗菌整理工藝使ZnO溶膠負載在棉織物上，并以富 有代表性菌種的革蘭氏陰性菌種大腸桿菌和革蘭氏陽性歯種金黃色葡 萄球菌為代表菌種，采用抑菌圈法進行檢驗，并以二次通用旋轉組合 設計方法設計實驗方案進行實驗，優化參數，以得到最佳抗菌工藝條 件；用掃描電鏡比較分析了棉織物原樣與處理樣的表面結構變化，并 探討了納米ZnO的抗菌機理及用ZnO處理棉織物后對其基本物理性能 的影響；最后附帶探討了經ZnO溶膠處理后的棉織物抗紫外線的研究。 本課.題最終得到如下的結論：1經XRD、ZeTar激光粒度對ZnO溶膠表征和檢測后，發現大多數ZnO 粒子的大小在77.6nm左右，這

4、說明納米氧化鋅的粒度粒徑已經達到 了納米級。在對納米氧化鋅溶膠制備的影響因素的探討中，經實驗 證明在下列條件中，制得的氧化鋅水溶膠是均勻和穩定的：r值（HQ 與金屈醇鹽的摩爾比）為40、PH值為6、溫度為609。2用ZnO溶膠對棉織物進行傳統的浸軋烘抗菌整理工藝，并采用二次 通用旋轉組合設計方法，利用隨機方向搜索法，得到大腸桿菌和金 黃色葡萄球菌最優抗菌工藝參數。ZnO溶膠濃度5.7600%、溫度為 44.6671* Cx 時間為 45.0226 分鐘，PH 為 6。3從掃描電鏡測試圖中可知，抗菌整理前后棉織物的表面形態發生了明 顯的變化，經過抗菌整理的棉布樣上均勻分散著許多非常微細的納米 Z

5、nO顆粒。這說明納米氧化鋅在應用在棉織物上時并沒有發生明顯的 團聚現象；處理后的棉織物的水洗50次后，耐水洗性效果仍然良好; 對經納米ZnO整理的棉織物進行抗菌性機理的探討后可知:納米ZnO 對棉織物的抗菌性能是由光催化機理和金屬離子溶出機理共同起作 用的結果。4經實驗后，發現經納米ZnO溶膠處理后的棉織物對其物理基本性能 有所彩響：棉織物潤濕性和透氣性幾乎沒有什么變化，白度略微增 加，斷裂強力、褶皺回復角略有降低，但是這些變化在實際使用中 是可以接受的。5在納米ZnO對棉織物抗紫外線的研究中，實驗結果發現在波長280 400nm范圍內，紫外線中UVA和UVB的透過率都很小，透過率分 別為1.

6、34%和2.08%, UPF為49.714。這說明整理后的棉織物具有 非常好的抗紫外線的作用。關鍵詞：棉織物，納米ZnO,抗菌劑，抗菌，抗紫外線Nanometer Antibacterial MaterialsTrepration AndExploration On TextilesApplicationABSTRACTIn the modem life ,cotton fabrics are more and more popular because of their excellent absorptance and wear-comfort,but they have poor micr

7、obiological resistance.Recently with imprcvement of people's life,they have demand for antibacterial textiles,so cotton's antibacterial finishing is more and more important.As antibacterial materialZinc has many merits such as high efficiency,perdurence,safe and so on I am studied in this di

8、ssertation that how to produce the sol-gel of nano-Zinc and give cotton fabrics good microorganism resistance.With special performance of nanometer materials,nano meter antibacterial agents are better than usual antibacterial agents.At present ,many nanometer antibacterial agents are power products

9、in the market.The former research shows that powery antibacterial agents cann'i distribute on the fabric because nanometer particulates are easy to gather together. In this dissertation,on the base of ZnC12,NaOH,PAAS,GPT- MS etc .use the Mirco-emulsification and sol-gel to make the Zinc oxide,th

10、en test the Zinc oxide particle with XRD and ZeTar laser granularity machine;on the premise of having no effect on handle of cotton fabric,we ue Pad-dry technique to make cotton fabrics antibacterial finishing with nanometer Zinc oxide antibacterial agents;on the representative test specimens of Kle

11、bsiellapneumoniae and Staphylococlus- Aureusheck-upthe cotton fabric with The Agar Plate Method,Adopting the universal rotatable experimenul design ,optimizing the parameters to obtain the reaction optimization condilions;analyzing the surfoce structure change between the original cotton fabric and

12、treated cotton fabric through the scanning electron microscope and studying the antibacterial mechanism of nanometer Zinc oxide and influence over the basic physical performance for the treated cotton fabric ;at last,studying the antiultraviolet radiation of cotton fabric with the nanometer Zinc oxi

13、de treatment.by means of specific experiments and analysis ,the following conclusions have been drawn out: 1. The results shows through the XRD and ZeTar that the Zinc oxide particulate is 77.6nm or so,which proves the granularity of Zinc oxideNanometer Antibacterial MaterialsTrepration AndExplorati

14、on On TextilesApplicationABSTRACTIn the modem life ,cotton fabrics are more and more popular because of their excellent absorptance and wear-comfort,but they have poor microbiological resistance.Recently with imprcvement of people's life,they have demand for antibacterial textiles,so cotton'

15、s antibacterial finishing is more and more important.As antibacterial materialZinc has many merits such as high efficiency,perdurence,safe and so on I am studied in this dissertation that how to produce the sol-gel of nano-Zinc and give cotton fabrics good microorganism resistance.With special perfo

16、rmance of nanometer materials,nano meter antibacterial agents are better than usual antibacterial agents.At present ,many nanometer antibacterial agents are power products in the market.The former research shows that powery antibacterial agents cann'i distribute on the fabric because nanometer p

17、articulates are easy to gather together. In this dissertation,on the base of ZnC12,NaOH,PAAS,GPT- MS etc .use the Mirco-emulsification and sol-gel to make the Zinc oxide,then test the Zinc oxide particle with XRD and ZeTar laser granularity machine;on the premise of having no effect on handle of cot

18、ton fabric,we ue Pad-dry technique to make cotton fabrics antibacterial finishing with nanometer Zinc oxide antibacterial agents;on the representative test specimens of Klebsiellapneumoniae and Staphylococlus- Aureusheck-upthe cotton fabric with The Agar Plate Method,Adopting the universal rotatable experimenul design ,optimizing the parameters to obtain the reaction optimization condilions;analyzing t