增強尼龍管材和管件

SY/T××××.2—××××SY/T6288—××××PAGE16PAGE1中華人民共和國住房和城鄉建設部發布CJ/T××××－××××××××-××-××實施中華人民共和國住房和城鄉建設部發布CJ/T××××－××××××××-××-××實施××××-××-××發布增強尼龍管材和管件Reinforcednylon

pipesandfittings征求意見稿CJ中華人民共和國城鎮建設行業標準備案號：SY/T6701—2007CJ/T××××—××××PAGEIIPAGEI目次TOC\o"1-3"\h\z前言 II1范圍 12規范性引用文件 13術語和定義、符號 13.1術語和定義 13.2符號 24材料 35要求 35.1外觀 35.2規格 35.3力學性能 65.4衛生性能 66試驗方法 66.1外觀 66.2尺寸測量 76.3力學性能 77檢驗規則 77.1檢驗分類 77.2檢驗項目 77.3出廠檢驗 87.4型式檢驗 88標志、包裝、運輸和貯存 98.1標志 98.2包裝 98.3運輸 98.4貯存 9附錄A（規范性附錄）增強尼龍管件結構和規格 10CJ/T××××—××××PAGE6PAGEII前言本標準按照GB/T1.1-2009《標準化工作導則第一部分：標準的結構和編寫》的規則起草。本標準由住房和城鄉建設部標準定額研究所提出。本標準由住房和城鄉建設部市政給水排水標準化技術委員會歸口。本標準起草單位：廣東科進尼龍管道制品有限公司、同濟大學航天航空與力學學院。本部分主要起草人：增強尼龍管材和管件

范圍本標準規定了增強尼龍管材和管件的術語和定義、符號、材料、要求、試驗方法、檢驗規則、標志、包裝、運輸和貯存等。本標準適用于公稱直徑不超過1000mm，壓力不超過1.6MPa，使用溫度不超過80℃的規范性引用文件下列文件對于本文件的應用是必不可少的。凡是注日期的引用文件，僅注日期的版本適用于本文件。凡是不注日期的引用文件，其最新版本（包括所有的修改單）適用于本文件。GB/T1040.1塑料拉伸性能的測定第1部分：總則（GB/T1040.1-2006，ISO527-1:1993，IDT）GB/T1040.2塑料拉伸性能的測定第2部分：模塑和擠塑塑料的試驗條件（GB1040.2-2006，ISO527-2:1993，IDT）GB/T3681塑料自然氣候暴曬試驗方法（GB/T3681-2011，ISO877:1994，EQV）GB/T6111流體輸送用熱塑性塑料管材耐內壓試驗方法（GB/T6111-2003，ISO1167:1996，IDT）GB/T6671熱塑性塑料管材縱向回縮率的測定（GB/T6671-2001，ISO2505:1994，EQV）GB/T8802熱塑性塑料管材、管件維卡軟化溫度的測定（GB/T8802-2001，ISO2507:1995，EQV）GB/T8804.3熱塑性塑料管材拉伸性能測定第3部分：聚烯烴管材（GB/T8804.3-2003，ISO6259-3:1997，EQV）GB/T8806塑料管道系統塑料部件尺寸的測定（GB/T8806-2008，ISO3126:2005，IDT）GB/T9647熱塑性塑料管材環剛度的測定（GB/T9647-2003，ISO9969:1995，EQV）GB/T13254工業用己內酰胺GB/T15560流體輸送用塑料管材液壓瞬時爆破和耐壓試驗方法GB/T19278熱塑性塑料管材、管件及閥門通用術語及其定義GB/T20674.1塑料管材和管件聚乙烯系統熔接第1部分：熱熔對接術語和定義、符號3.1術語和定義GB/T19278確立的以及下列術語及定義適用于本文件。3.公稱直徑nominaldiameter與管材（外）直徑有關的名義數值。3.平均外徑meanoutsidediameter管材外圓周長的測量平均值除以圓周率（π）所得的值，精確到0.1mm，小數點后第二位非零數字進位。3.最小平均外徑minimummeanoutsidediameter平均外直徑的最小值。3.最大平均外徑maximummeanoutsidediameter平均外徑的最大值。3.任一點外徑outsidediameteratanypoint通過管材任一點所在橫截面測量的外直徑，精確到0.1mm，小數點后第二位非零數字進位。3.壁厚wallthickness管材壁厚的規定值。3.平均壁厚meanwallthickness沿管材的同一橫斷面至少六等分測得壁厚的算術平均值，應包括測得的最大值和最小值，精確到0.1mm，小數點后第二位非零數字進位。3.任一點壁厚wallthicknessatanypoint管材橫截面上任一點壁厚的測量值，精確到0.1mm，小數點后第二位非零數字進位。3.最小壁厚minimumwallthickness管材橫截面上任一點壁厚的最小值。3.增強尼龍管材和管件nylonpipes將己內酰胺熱熔脫水，添加適量增強劑（玻璃纖維、高嶺土）和催化劑，使之改性成增強尼龍，在常壓下采用離心或靜態澆鑄工藝制造的增強尼龍管材和管件。3.2符號DN—公稱直徑，單位為毫米。dem—平均外徑，單位為毫米。dem,min—最小平均外徑，單位為毫米。dem,max—最大平均外徑，單位為毫米。dey——任一點外徑，單位為毫米。δ——壁厚，單位為毫米。δm——平均壁厚，單位為毫米。δy——任一點壁厚，單位為毫米。δy,min——最小壁厚，單位為毫米。L—管材的長度，單位為毫米。材料原料己內酰胺應符合GB/T13254的規定，用于生產輸送原水、生活飲用水等管道的己內酰胺應符合相應的衛生標準。要求5.1外觀增強尼龍管材和管件應為微黃色（亦可根據用戶需要制成其他顏色），內外表面應清潔、平滑，不允許有氣泡、明顯劃傷、凹陷、雜質、顏色不均等缺陷，管端面應平齊、邊棱應無毛刺，并與管軸線垂直。5.2規格5.2.15.2.1.1外直徑5.2.1.1.1增強尼龍管材（不帶法蘭）各公稱直徑和壓力等級下的管道外直徑和管壁厚度的允許偏差見圖1和表1。圖1增強尼龍管材（不帶法蘭）結構表1增強尼龍管材（不帶法蘭）規格尺寸單位：毫米DND外徑允差δ長度L0.6MPa0.8MPa1.0MPa1.2MPa1.6MPa5066±1.02.42.83.33.74.53000、6000（允許偏差：±0.5%或±10mm兩者中的大值）6588±1.02.73.23.84.35.280100±1.02.93.54.14.75.8100120±1.53.34.04.85.46.8125145±1.53.84.75.56.48.0150170±1.54.35.36.37.39.2200224±2.05.36.78.09.311.8250275±2.06.38.09.611.214.3300330±2.07.39.411.313.216.9350380±2.08.310.612.915.119.3400430±2.09.311.914.416.921.7450480±2.510.313.316.219.024.4500530±2.511.314.617.820.926.8600630±2.513.317.221.024.731.8700730±3.015.219.724.128.4-800820±3.016.821.826.631.4-900920±3.018.724.329.835.1-10001020±3.520.626.832.938.8-說明：壓力等級為0.6MPa的管材的環剛度不小于1.3kPa；壓力等級為0.8MPa的管材的環剛度不小于2.9kPa；壓力等級為1.0MPa的管材的環剛度不小于5.5kPa；壓力等級為1.2MPa的管材的環剛度不小于9.2kPa；壓力等級為1.6MPa的管材的環剛度不小于22kPa。5.2.1.1.2增強尼龍管材各公稱直徑和壓力等級下的管道外直徑和管壁厚度的允許偏差見圖2和表2。5.2.1.1.3管端的法蘭面設有3~4條環形凸線，同時，法蘭面與法蘭面對接處可加一專用橡膠墊片以增強密封性。I處放大圖圖2增強尼龍管材結構表2增強尼龍管材規格尺寸單位：毫米DN管子法蘭dHδL（×103）DD1D2bdnfrPN6（0.6MPa）50658066881002.42.72.916018019512514516099118132242526181818448333851051206661001251501201451703.33.84.32152452801802102401561842112830321818228883331451752008882002502242755.36.333540529535026631935382222812332603158103003504003303804307.38.39.346052058040046051537042948040454822222612161644437042548010101045050060070048053063073010.311.313.315.26407057808955656207258405305826827945050556526263030202020244455530585685785121212128009001000820920102016.818.720.610101110122095010501160901100111127075803333362428285558809801080151515DN管子法蘭dHδL（×103）DD1D2bdnfrPN10（1.0MPa）50658066881003.33.84.116018019512514516099118132242526181818448333851051206661001251501201451704.85.56.32152452801802102401561842112830321818228883331451752008882002502242758.09.6335405295350266319353822228123326031581030035040033038043011.312.914.446052058040046051537042948040454822222612161644437042548010101045050060070048653664074016.217.821.053058268250505526263020202044453058568512121224.18958407946530245785128009001000820920102026.629.832.910101110122095010501160901100111127075803333362428285558809801080151515PN16（1.6MPa）50658066881004.55.25.816018019512514516099118132242526181818448333851051206661001251501201451756.88.09.221524528018021024015618421128303218182288833314517520088820025022427511.814.33354052953552663193538222612123326031581030035040033038043016.919.321.746052058041047052537042948040454826263012161644437042548010101045050048653624.426.86407055856505486095050303320204453058512125.2.1.2長度尼龍管的長度一般為3m，6m，長度的允許偏差為±10mm或±0.005L兩者中的大值。5.2.1對于管材和管件任一截面的管壁平均厚度應不小于規定的設計厚度（見表1和表2），其中最小管壁厚度應不小于設計厚度的90％。5.2.2管件彎頭、等徑三通、等徑四通、異徑三通、異徑四通、同心異徑管、偏心異徑管的尺寸要求見附錄A.。5.3力學性能增強尼龍管材和管件力學性能應符合表3的規定。表3增強尼龍管材和管件材力學性能表序號項目單位技術要求試驗方法1拉伸屈服強度MPa≥606.32拉伸斷裂伸長率%≥12063縱向回縮率%≤364維卡軟化點℃≥14065水壓爆破試驗MPa≥3×PN66環剛度kPa≥467靜水壓試驗MPa作用1.5PN內水壓，不滲漏、不破裂.68耐候性試驗（累計接受≥3.5GJ/m2老化能量后）MPa≥3×PN65.4衛生性能用于原水及飲用水輸配的管材和管件的衛生性能應符合相關衛生標準的規定。試驗方法6.1外觀目測，內壁可借助光源在逆光下進行目測觀察。6.2尺寸測量6.2.1外直徑按GB/T8806的規定檢驗。6.2.2按GB/T8806的規定檢驗。6.2.3按GB/T8806的規定檢驗。6.2.4按GB/T8806的規定檢驗。6.3力學性能6.3.1按GB/T8804.3規定檢驗。6.3.2按GB/T8804.3規定檢驗。6.3.按GB/T6671規定檢驗。6.3.4維卡軟化點按GB/T8802規定檢驗。6.3.5水壓爆破試驗按GB/T15560規定檢驗。6.3.6環剛度按GB/T9647規定檢驗。6.3.7靜水壓試驗按GB/T6111的規定試驗，試驗壓力為公稱壓力的1.5倍，穩壓10min后，不滲漏、不破裂。6.3.8按GB/T3681規定使管材累計接受大于等于3.5GJ/m2老化能量后，再按照GB/T6111的規定進行水壓爆破檢驗。檢驗規則7.1檢驗分類檢驗分為出廠檢驗和型式檢驗。7.2檢驗項目出廠檢驗和型式檢驗的檢驗項目見表4表4出廠檢驗和型式檢驗的檢驗項目序號項目出廠檢驗型式檢驗1外觀√√2外直徑√√3長度√√4管壁壁厚√√5拉伸屈服強度√6拉伸斷裂伸長率√7縱向回縮率√8維卡軟化點√9水壓爆破試驗√10環剛度√11靜水壓試驗√√12耐候性試驗√7.3出廠檢驗7.3.1檢驗方案7.3.1.1每一根增強尼龍管材和管件均應進行外觀、外直徑、管壁厚度、長度的檢驗。7.3.1.2以同一原料、配方和工藝連續生產的同一規格產品為一批（產品每批數量不超過200件，生產期15天尚不足200根，以15天產量為一批），每批抽樣1件進行靜水壓試驗。7.3.2判定7.3.2.1外觀、外直徑、管壁厚度、長度檢驗均應達到相應要求，否則判該件產品不合格。7.3.2.2靜水壓試驗檢驗合格，判該批產品合格。如果檢驗不合格，可加倍抽樣，復檢結果應達到要求，否則，判該批產品不合格。7.4型式檢驗7.4.1有下列情況之一時，應進行型式檢驗：a）新產品或老產品的轉產試制定型鑒定時；b）正式投產后，當產品的原料、結構、工藝有較大變動可能影響產品性能時；c）正常生產時，應每三年進行一次檢驗；d）產品長期停產（三個月以上）再恢復生產時；e）出廠檢驗結果與最近一次型式檢驗結果存在較大差異時；f）國家質量監督機構提出進行型式檢驗時。7.4.2抽樣與判定以同一原料、配方和工藝連續生產的同一規格產品為一批（產品每批數量不超過200件，生產期15天尚不足200根，以15天產量為一批），抽樣1件進行表4規定項目的檢驗。檢驗項目中不合格項超過2項時，判該批產品不合格；如不合格項不多于2項，可加倍抽樣，對不合格項復檢，復檢項目應全部達到要求，否則，判該批產品不合格。標志、包裝、運輸和貯存8.1標志所有產品都應有標識。采用標識的顏色應區別于管材和管件的顏色，標識內容都應清晰可辨。標識內容應包括：a）生產企業名稱；b）產品名稱、公稱直徑、壓力等級、長度和執行標準號；c）產品編號及生產日期或批號。8.2包裝每件產品均應獨立包裝。產品的法蘭面應采用軟性材料包裝防護。8.3運輸8.3.1起吊宜用柔性繩索，應在吊索與管道棱角處襯墊橡膠或其他柔性物。8.3.2起吊時必須采用雙點起吊，不應單點起吊。8.3.3起吊及裝卸時，應輕起輕放，不應拋擲。8.3.4運輸時應固定牢靠，應采用臥式堆放，且端面法蘭應錯開，避免損壞密封面。8.3.5在運輸和裝卸過程中管材和管件不應受到劇烈的撞擊。8.4貯存8.4.1應按產品類型、規格、壓力等級分類堆放；9.4.2產品應貯存于整潔、平穩、墊實、無熱源的庫房內，堆放整齊，管材堆放高度不應超過2.5m，不應露天存放，避免陽光直射。

（規范性附錄）

增強尼龍管件結構和規格A.1增強尼龍彎頭結構和規格增強尼龍彎頭結構見圖A.1，規格應符合表A.1的規定。圖A.1增強尼龍彎頭結構表A.1增強尼龍彎頭規格單位：毫米DNDD1D2fbDmrδndA90o45oPN1050160125993248053.9418125656518014511832510564.5418145658019516013232611465.08181508010021518015632813465.781820010012524521018433016166.681822511515028024021133218667.682225012520033529526633524089.6822300140250405350319338292811.51222300165300460400370440342813.61222300190350520460429445396815.516223501904005805154804484481017.316264002004506405655304504981019.420264502205007056205824505521021.320265002406007807256825556851225.220306002607008958407945658001229.0243070029080010109509015708801532.024338003309001110105010015759801535.72833900373100012201160111258010801539.528361000415PN1650160125993248565.4418125656518014511832510566.3418145658019516013232612067.081815080PN1610021518015632814588.181820010012524521018433017589.6818225115150280240211332200811.0822250125200335295266335260814.212223001402504053553193383151017.112263001653004604103704403701020.312263001903505204704294454251023.216263501904005805254804484801026.116304002004506405855304505301229.320304502205007056505824505851232.22036500240A.2增強尼龍等徑三通、四通結構和規格增強尼龍等徑三通、四通結構見圖A.2、規格應符合表A.2的規定。圖A.2增強尼龍等徑三通、四通結構表A.2增強尼龍等徑三通、四通規格單位：毫米DNDD1D2fbDmrδndAPN1050160125993248053.94181256518014511832510564.54181458019516013232611465.081815010021518015632813465.781820012524521018433016166.681822515028024021133218667.682225020033529526633524089.6822300250405350319338292811.51222300300460400370440342813.61222300350520460429445396815.516223504005805154804484481017.316264004506405655304504981019.420264505007056205824505521021.320265006007807256825556851225.220306007008958407945658001229.0243062080010109509015708801532.024336909001110105010015759801535.72833700100012201160111258010801539.52836750PN1650160125993248565.44181256518014511832510566.34181458019516011832612067.081815010021518013232814588.181820012524521015633017589.6818225150280240184332200811.0822250200335295211335260814.212223002504053552663383151017.112263003004604103194403701020.312263003505204703704454251023.216263504005805254294484801026.116304004506405854804505301229.320304505007056505304505851232.22033500A.3增強尼龍異徑三通、四通結構和規格增強尼龍異徑三通、四通結構見圖A.3，規格應符合表A.3的規定。圖A.3增強尼龍異徑三通、四通結構

表A.3增強尼龍異徑三通、四通規格單位：毫米DNA1A2b1b2δ1δ2Dm1Dm2r1r2備注PN10PN16PN10PN1650×2512510024203.95.42.83.5805554法蘭連接尺寸標準：GB/T9119/HG20592-RF50×4012512524203.95.43.54.980705465×2514512525204.56.32.83.5105556465×4014514525204.56.33.54.9105706465×5014514525244.56.33.95.4105806580×2515015026205.07.02.83.5114556480×4015015026205.07.03.54.9114706480×5015015026245.07.03.95.4114806580×6515015026255.07.04.56.311410566100×2515015028205.78.12.83.51345564100×4015015028205.78.13.54.91347064100×5020015028245.78.13.95.41348065100×6520017528255.78.14.56.313410566100×8020017528265.78.15.07.013411466125×2515015030206.69.62.83.51755584125×4015015030206.69.63.54.91757084125×5022517530246.69.63.95.41758085125×6522517530256.69.64.56.317510586125×8022517530266.69.65.07.017511486125×10022517530286.69.65.78.117514586150×2515016032207.611.02.83.52005584150×4015016032207.611.03.54.92007084150×5025020032247.611.03.95.42008085150×6525020032257.611.04.56.320010586150×8025020032267.611.05.07.020011486150×10025020032287.611.05.78.120014586150×12525020032307.611.06.69.620017588200×2515019035209.614.22.83.52605584200×4015020035209.614.23.54.92607084200×5030022535249.614.23.95.42608085200×6530022535259.614.24.56.326010586200×8030022535269.614.25.07.026011486200×10030022535289.614.25.78.126014586200×12530022535309.614.26.69.626017588200×15030022535329.614.27.611.026020088250×25150215382011.517.12.83.531555104250×40150240382011.517.13.54.931570104表A.3（續）DNA1A2b1b2δ1δ2Dm1Dm2r1r2備注PN10PN16PN10PN16250×50200240382411.517.13.95.431580105法蘭連接尺寸標準：GB/T9119/HG20592-RF250×65300250382511.517.14.56.3315105106250×80300250382611.517.15.07.0315114106250×100300250382811.517.15.78.1315145106250×125300250383011.517.16.69.6315175108250×150300250383211.517.17.611.0315200108250×200300275383511.517.19.614.2315260108300×25150240402013.620.32.83.537055104300×40200260402013.620.33.54.937070104300×50200260402413.620.33.95.437080105300×65300275402513.620.34.56.3370105106300×80300275402613.620.35.07.0370120106300×100300275402813.620.35.78.1370145108300×125300275403013.620.36.69.6370175108300×150300275403213.620.37.611.0370200108300×200300300403513.620.39.614.2370260108300×250300300403813.620.311.517.13703151010350×25150260452015.523.22.83.542555104350×40200290452015.523.23.54.942570104350×50200300452415.523.23.95.442580105350×65300300452515.523.24.56.3425105106350×80300300452615.523.25.07.0425114106350×100300300452815.523.25.78.1425145108350×125300300453015.523.26.69.6425175108350×150300300453215.523.27.611.0425200108350×200300300453515.523.29.614.2425260108350×250300325453815.523.211.517.14253151010350×300300325454015.523.213.620.34253701010400×25150290482017.326.12.83.548055104400×40200325482017.326.13.54.948070104400×50200325482417.326.13.95.448080105400×65300325482517.326.14.56.3480105106400×80300325482617.326.15.07.0480114106400×100300325482817.326.15.78.1480145108400×125300325483017.326.16.69.6480175108400×150300325483217.326.17.611.0480200108400×200300350483517.326.19.614.2480260108400×250300350483817.326.111.517.14803151010400×300400350484017.326.113.620.34803701010表A.3（續）DNA1A2b1b2δ1δ2Dm1Dm2r1r2備注PN10PN16PN10PN16400×350400375484517.326.115.523.24804251010法蘭連接尺寸標準：GB/T9119/HG20592-RF450×25200310502019.429.32.83.553055124450×40250350502019.429.33.54.953070124450×50250350502419.429.33.95.453080125450×65300350502519.429.34.56.3530105126450×80300350502619.429.35.07.0530114126450×100300350502819.429.35.78.1530145128450×125300350503019.429.36.69.6530175128450×150300350503219.429.37.611.0530200128450×200300375503519.429.39.614.2530260128450×250300375503819.429.311.517.15303151210450×300400400504019.429.313.620.35303701210450×350400400504519.429.315.523.25304251210450×400400400504819.429.317.326.15304801210500×25200340502021.332.22.83.558555124500×40250375502021.332.23.54.958570124500×50250375502421.332.23.95.458580125500×65300375502521.332.24.56.3585105126500×80300375502621.332.25.07.0585114126500×100300375502821.332.25.78.1585145128500×125300375503021.332.26.69.6585175128500×150300375503221.332.27.611.0585200128500×200300400503521.332.29.614.2585260128500×250400400503821.332.211.517.15853151210500×300400425504021.332.213.620.35853701210500×350400425504521.332.215.523.25854251210500×400400425504821.332.217.326.15854801210500×450400450505021.332.219.429.35855301212600×25200400552025.22.868555124600×40250400552025.23.568570124600×50300400552425.23.968580125600×65300400552525.24.5685105126600×80300400552625.25.0685114126600×100300400552825.25.7685145128600×125300400553025.26.6685175128600×150300400553225.27.6685200128600×200300400553525.29.6685260128600×250300425553825.211.56853151210600×300400425554025.213.66853701210表A.3（續）DNA1A2b1b2δ1δ2Dm1Dm2r1r2備注PN10PN16PN10PN16600×350400450554525.215.56854251210法蘭連接尺寸標準：GB/T9119/HG20592-RF600×400450450554825.217.36854801210600×450450450555025.219.46855301212600×500450500555025.221.36855851212700×25200450652029.02.880055124700×40250450652029.03.580070124700×50250450652429.03.980080125700×65250450652529.24.5800105126700×80400450652629.05.0800114126700×100400450652829.05.7800145128700×125400450653029.06.6800175128700×150400450653229.07.6800200128700×200400450653529.29.6800260128700×250400475653829.011.58003151210700×300450475654029.013.68003701210700×350450500654529.015.58004251210700×400450500654829.017.38004801210700×450450550655029.219.48005301212700×500450550655029.021.38005851212700×600500575655529.025.28006851212800×25300550702032.02.888055154800×40300550702032.03.588070154800×50300550702432.03.988080155800×65300550702532.04.5880105156800×80400550702632.05.0880114156800×100400550702832.05.7880145158800×125400550703032.06.6880175158800×150400550703232.07.6880200158800×200400550703532.09.6880260158800×250400550703832.011.58803151510800×300500550704032.013.68803701510800×350500550704532.015.58804251510800×400500550704832.017.38804801510800×450500550705032.019.48805301512800×500500550705032.021.38805851512800×600600600705532.025.28806851512800×700600600706532.029.08808001515900×25300600752035.72.898055154900×40300600752035.73.598070154表A.3（續）DNA1A2b1b2δ1δ2Dm1Dm2r1r2備注PN10PN16PN10PN16900×50300600752435.73.998080155法蘭連接尺寸標準：GB/T9119/HG20592-RF900×65300600752535.74.5980105156900×80400600752635.75.0980114156900×100400600752835.75.7980145158900×125400600753035.76.6980175158900×150400600753235.77.6980200158900×200400600753535.79.6980260158900×250400600753835.711.59803151510900×300500600754035.713.69803701510900×350500600754535.715.59804251510900×400500600754835.717.39804801510900×450500600755035.719.49805301512900×500500600755035.721.39805851512900×600600600755535.725.29806851512900×700600600756535.729.09808001515900×800700600757035.732.098088015151000×25300650802039.52.81080551541000×40300650802039.53.51080701541000×50300650802439.53.91080801551000×65300650802539.54.510801051561000×80400650802639.55.010801141561000×100400650802839.55.710801451581000×125400650803039.56.610801751581000×150400650803239.57.610802001581000×200400650803539.59.610802601581000×250400650803839.511.5108031515101000×300500650804039.513.6108037015101000×350500650804539.515.5108042515101000×400500650804839.517.3108048015101000×450500650805039.519.4108053015121000×500500650805039.521.3108058515121000×600600650805539.525.2108068515121000×700600650806539.529.0108080015151000×800700650807039.532.0108088015151000×9007