文稿說明案例

能基礎培系統設計的內主要參考規GB50015-2003 Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎能基礎培家用熱水需求 1住宅有自備熱水供應和沐浴設備2每人每3494 5 6摘自：GB50015-2003 Internal -MKT1|9/1/2012|?RobertBoschGmbH2012Allalsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培各 照fN888Hha：水平面年平均日輻照量 Hlt：當?shù)鼐暥葍A角平面總輻照量，MJ/(m2.a)Ta：年平均環境溫：水平面年總輻照量 Hla：當Sy：年平均每日的日照小時數 地緯度傾角平面年平均日輻照亮 f：年能保證率推薦范 N：回收年限允許值 Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培 能保I≥II5400~III4200~IV Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培集熱器面積的1估算法：用于系統面積小，要求不嚴或客戶需要大致了解基本情況2計算法：一般用于設計要求比較嚴格，特別是通過設計院來進行設 6Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitation6editingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培估算100L1DHW加熱：1m21m2集熱器最低1KW熱負荷=100-平板集熱器不同季節的產水量夏季:100-冬 -7Internal -MKT1|9/1/2012|?RobertBoschGmbH2012Alleditingdistributionaswellasintheeventofapplicationsforindustrialpropertyalsoregardinganydisposalexploitation能基本培典型城市集熱器產水量（全年平均,FCC220-2V核算地當?shù)鼐暥刃泵嫒掌骄椪杖招嗜债a(chǎn)熱L/1.94m2(L/塊沈...長杭太濟西鄭廣海. Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty步驟常用參數,確定常用參數,熱水計算e.g40*40.24L/S;淋浴器5.每100升水由1KW電加熱0.24L/S;淋浴器5.每100升水由1KW電加熱加熱溫度30度所需時間：3.2容積：最?。?.2*最大：.*用水集熱器可提供水量：每天每平米（毛積）在溫升30oC時，加熱熱水;選 容積為 ），e.g200/60=3.3m2，并需要選擇3.3/2.09=1.6塊，選擇2塊。 9Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitation9editingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培基本參 人(2)用 (熱 )qr,每人每日用熱 以熱水計算，取L/人·d

Qhk

mqrctrtLQr設計(1)設計小時耗熱

1.163(t

t

):

Q

1.163設計小時熱水

qrh：即為集熱系統循環泵的qx:該流量即為熱水供水系統泵流量

Uo

qr0.2Ng·T

(4)熱水供水管的設計秒流量 ：最大用水時衛生器，查《建筑給水排水設計規范》(GB50015－2003)水管的設計秒流量Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培 對能熱水系統，由于受自然條件輻射一天之內隨時間變化)不可能全天24小時滿足設、能集熱系統功率和用戶用水量之間的關系對于全天24小時供熱水的系統：設計容量V=3~4.5*設計小時用水量qx容積式熱交換加熱面 Cr容積式熱交換器按系統最不利工況， 能系統 工作時的條件確定 q.k.貯水容容積式熱交換器保證系統用戶45min設計小時耗熱Internal -MKT1|9/1/2012|?RobertBoschGmbH2012Alleditingdistributionaswellasintheeventofapplicationsforindustrialpropertyalsoregardinganydisposalexploitation能基礎培集熱器面積計算公式 QwCw(t ti) J Actend:儲內水的終止溫度（用水溫度),Cw水的定壓比熱容，4.18KJ/（㎏·oCJ：年平均或月平均日輻照量，KJf：能保證率，無量綱，30-80%，根據用途選ηcd：集熱器全日月均或年均集熱效率，可取 ~注意：該計算結果是以集熱器按正南方向、當?shù)鼐暥葍A斜角度計算，如果偏離需要進行修Thermotechnology Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培朝向、傾斜角東南西 Internal -MKT1|9/1/2012|?RobertBoschGmbH2012Allalsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培 集熱器陣列流量確定：按每塊集熱器50L/h流量計 能防凍液的壓力損失：45：55防凍液，其壓降按1.2倍水壓降計算，在40：60防凍液，其壓按照1.3倍水壓降計算 水作為循環介質僅可在室外溫度不會低于5oC地方 自動補水系統使用在能系 PH:7.5-1001500氯化物含量30如果不能保證上述條件，博世建議使用防凍液作為循環介質，例如使用45%：55% SolarFluidWTF10(10Literscan) SolarFluidWTF25”(25Literscan) Internal|TTCB/MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培計算機模擬軟Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培計算機模擬設Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培計算機模Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培計算機模Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培能熱水工程數據 Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialpropertyInternal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培隔膜式膨脹 Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培系統壓 系統最大壓力（取決于設備的使

(6 安全閥

((0,9bar

(5,4 系統冷卻狀態下的壓 (1,9-2,2-0,3

系統的靜壓（取決于高度差

+0,7

pV膨脹罐Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培隔膜式膨脹罐容積計影響因系統內容積總量計算 = ·n+V

膨脹系數n=0,085

D(p-p

VD=pe=pSV·0,9pe=pSV–0,2barbeiSVp0=0,1hstat+0,7bar,abermind.1,5bar( pVp00,3bar,abermind1,5bar降溫罐Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培商業系統膨脹罐VA.(VA+VD+VR

.(pe- >1,6

計算參數Vn,min膨脹罐最小容積lVA系統循環液體量ln液體膨脹系數 集熱器內溶液量（蒸發量 =(V.n+ +V

n,

單個集熱器灌液量 高于回水管道 能管道內溶液Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培膨脹罐工作空載 冷態 熱態Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基粗培系統安全組 能基礎培家 能系統組

1、集熱2、集熱器溫度傳3、排氣裝4、過載保5、管路和保溫6 能工作7、止回8、冷水止落9、循環10、控制 系導熱介12、安全13、接收14、膨脹15、控制線16 溫度傳感1718、導熱盤19、恒溫調Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培系統組件、安全、重力止回如果的溫度比集熱器的溫度高，則熱水從流向集熱器的反循環可能會產生，因此而被冷卻（特別是在夜晚，與Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培系統組件、安全安全閥(6 Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培放氣閥(附件 注意Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培設計，安裝，組洗浴用水混水閥（選件熱水溫度可在30-65oC之間調注意TInternal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培安全故障沒有安裝熱水 Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培安全管道熱絕Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培系統組件、安全、 防凍Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培安全，故障錯誤！使用不經允許的能傳熱介 Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培安全，故障能循環中存在造成系統能產熱量減 Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培

在灌液結束 FCC- FKS-Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培傳感器安裝 Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培設計，安裝，組系統沖洗灌液注Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培系統組件、安全不要在陽光直曬時，向系統內充（Temp<注Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培能與建 能基礎培鑲嵌Internal|TT/STR|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationreproductiondistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培Internal| -MKT1|9/1/2012|?RobertBoschGmbH2012Allrights alsoregardinganydisposalexploitationreproductioneditingdistributionaswellasintheeventofapplicationsforindustrialpropertyrights能基礎培BuildingInSight=Outofn能基礎培BuildingInternal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培Volume:China-Multi-family,total90m2Connectiontodistrict6m3HotVolume:China-Multi-family,total240Connectiontodistrict14m3HotInternal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培Volume:China-能基礎培漂頂Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培不同屋面安裝Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheeventofapplicationsforindustrialproperty能基礎培建筑外立面 能表面， 立面Internal -MKT1|9/1/2012|?RobertBoschGmbH2012All alsoregardinganydisposalexploitationeditingdistributionaswellasintheevent