碎磚骨料再生混凝土的研究利用

1、1.碎磚骨料再生混凝土的研究利用碎磚骨料再生混凝土的研究利用Research on the mixture of recycled brick aggregate concrete2.再生混凝土抗壓抗拉強度取值研再生混凝土抗壓抗拉強度取值研究究On Values of Compressive Strength and Tensile Strength of Recycled Aggregate Concrete3.再生混凝土框架抗震性能試驗研再生混凝土框架抗震性能試驗研究究Experimental Research on Seismic Beheavior of Recycled Concre

2、te Frame1. 1.前言前言?xún)?yōu)點：我國粘土磚廢料問題等待解決，解決此問題可以變廢為寶，帶優點：我國粘土磚廢料問題等待解決，解決此問題可以變廢為寶，帶來經濟效益還能保護人類生存環境。來經濟效益還能保護人類生存環境。缺點：碎磚骨料代替石料缺點：碎磚骨料代替石料, ,再生砼強度等級，抗震等級降低。再生砼強度等級，抗震等級降低。2. 2.試驗研究試驗研究2.12.1原材料試驗原材料試驗2.22.2試驗設計試驗設計3 3結果分析結果分析3.13.1配合比參數顯著性分析配合比參數顯著性分析3.23.2確定最佳配合比確定最佳配合比3.33.3工程性能分析工程性能分析.1拌合物和易性拌合

3、物和易性.2砼強度砼強度.3砼抗震等級砼抗震等級1.IntroductionAdvantages: The problem of waste brick needs to be solved in China,After do it, economic benefits will be gained ,and our living environment will be protected.Disadvantages: Strength and seismic grade of recycled brick aggregate concrete will be

4、ruduced when stone aggregate replaces brick aggregate.2.Experimental study2.1 Test raw materials 2.2 Experimental design3.Results analysis3.1 Significance analysis of mixture-ratio parameters 3.2 The optimum mixture-ratio 3.3 Engineering performance analysis3.3.1 Workability of mixture3.3.2 Strength

5、 of concrete3.3.3 Seismic grade of concrete1.摘要：摘要：用正交法試驗分析了碎磚骨料混凝土的配合比，提出水灰比和碎磚骨料摻量分別是影響混凝土強度和流動性的主要因素。倡導用碎磚做混凝土骨料，保護生態環境。關鍵詞：關鍵詞：碎磚骨料混凝土；生態環境；建筑節能；工程性能Abstract：The mixture of brick aggregate concrete is studied in orthogonal experiment design The paper summarizes that primary factors of strength a

6、nd fluidity are respectively water-cement ratio and brick aggregateIt calls for using waste brick as aggregate of concrete to protect environmentKeywords：Brick aggregate concrete；ecological environment；building energy efficiency；engineering properties3. 3.摘要：摘要：本文通過5榀再生骨料摻量分別為30、50、100再生混凝土框架和1榀普通混凝

7、土框架的低周反復荷載試驗，研究了再生混凝土框架的抗震性能，主要包括框架的破壞現象、破壞機制、滯回曲線、骨架曲線、特征荷載和特征位移、剛度退化和耗能能力等，并和普通混凝土框架進行對比分析。研究表明，再生混凝土框架有較好的抗震性能，隨著再生骨料摻量的增加，再生混凝土框架的抗震性能沒有明顯降低。再生混凝土框架應用于實際工程是可行的。 本文還通過1榀用再生輕質砌塊充填、再生骨料摻量為50的再生混凝土框架的低周反復荷載試驗，研究了填充墻再生混凝土框架的破壞現象、破壞機制、滯回曲線、骨架曲線、特征荷載和特征位移、剛度退化和耗能能力等，并和其它框架試驗結果進行對比分析。研究表明，填充墻和框架共同工作性能良好

8、，框架剛度和抵抗水平荷載的能力大大加強，其變形和耗能能力較差，同時填充墻對主體框架結構的影響應引起設計者重視。 文中用有限元分析程序ANSYS對再生混凝土框架的非線性受力性能進行模擬，并和試驗結果進行對比分析。分析表明，理論計算結果和試驗結果吻合較好，可以作為工程設計的依據，用ANSYS程序?qū)υ偕炷量蚣芙Y(jié)構進行受力分析是可行的。 Abstract:This paper through experiments of five recycled aggregate concrete frames with contain recycled aggregate proportion of 30%

9、 、 50% 、 100%, and one common concrete frame under low reversed cyclic loads and invariable vertical loads, seismic behavior of recycled concrete frame were studied, such as failure pattern, hysteresis loops, displacement ductility, deterioration of stiffness and energy dissipation etc, and compared

10、 with natural concrete frame. The test results show that recycled aggregate concrete frames have well seismic performance, and with the increasing of recycled aggregate proportion, the seismic performances of recycled aggregate concrete frames have not play down obviously. This indicated that recycl

11、ed aggregate concrete frame apply to practicality engineering is feasible.This paper still through experiments of one recycled aggregate concrete frame with contain recycled aggregate proportion of 50%, and infilled with recycled lightweight masonry blocks under low reversed cyclic loads and invaria

12、ble vertical loads, seismic behavior of recycled concrete frame infilled with recycled lightweight masonry blocks were studied, such as failure pattern, hysteresis loops, displacement ductility, deterioration of stiffness and energy dissipation etc, and compared with other concrete frames. The test

13、results show that infilled wall and frame cam work together well, stiffness and capacity of resistive horizontal loads of frame are strengthened obviously, but deformation and energy dissipation performance are weakly than other frames, and the influences of infilled wall of frame on main frame stru

14、cture should arouse attention of designers.Computer simulations on all reinforced concrete frames under low reversed cyclic lateral loading have been performed via ANSYS a great finite element analysis program on the basis of non-linear finite element analysis theory on recycled concrete, and compar

15、ed with test results. 前言 粘土磚作為傳統的建筑材料，在全國各地均有大量生產，盡管?chē)?guó)家近年來禁止在大型中心城市使用粘土實心磚，但在經濟欠發達地區和邊遠地區依舊生產使用。就是在中心城市，生產和使用符合政策規定的粘土空心磚也是允許的，而且發展迅猛，由此產生的粘土磚廢料在一些省份有增無減，占地和污染環境的壓力依然存在。另外，建筑物建造、拆除中產生的碎磚、碎瓦塊，粘土磚質量檢測的棄料等，都增大了這方面的壓力。因此，如何有效地利用這些廢磚是一個亟待解決的問題。 本文探討了將廢磚破碎后用作混凝土骨料的可行性，研究碎磚骨料混凝土配合比設計的方法，目的是促進廢磚資源化再生利用，其成果尤其

16、適用于缺乏天然骨料的地區。IntroductionClay brick as a traditional building materials,have a large number of production all over the country , and is widely used in the underdeveloped regions and remote areas although the center of the large cities shall be forbidden to use clay solid brick in recent years . In t

17、he center of city, the production and use is allowed according to the State Policy, and developing rapidly,but the waste of clay brick have increased in some provinces, which caused covering and pollution pressure . In addition,the pressurer of rubble,crock and clay brick etc. have also been increas

18、ed when building is contrusted or demolished .Therefore, how to effectively use these waste brick is a problem to be solved. This article discusses the feasibility used for the concrete aggregate of the waste brick after crushing , and researches the design method of brick aggregate concrete mixture

19、 ratio , which purpose is to promote recycling waste brick, its achievement is especially suitable to the area lacking of natural aggregate.試驗原材料 膠凝材料用32.5普通水泥，細骨料用天然河砂。粗骨料有兩種，一是用普通碎石，二是用碎磚做粗骨料。試驗設計 正交設計是一種安排多因素試驗的數學方法。文章通過正交試驗設計，計算分析水灰比、砂率，以及碎磚骨料取代碎石骨料的百分率三個配合比參數對混凝土強度影響的顯著程度，探討碎磚骨料混凝土的配合比設計規律，確定碎磚骨料混凝土的最優配合比，為今后廢磚骨料混凝土的商品化使用提供依據。raw materials32.5portland cement ,natural river sand,rubbleordinary gravelExperim