FM-BPM15.2-F002-V1 工作危險性檢查單JSA checklist

1、區域/Region: 營運點/Site: _ 日期/Date: _ 工作危險性檢查單JSA CHECKLIST 危險性HAZARDS控制措施CONTROL MEASURES 在適合處打勾Check which apply 需要時補充說明Add further as required1.0 物理的 PHYSICAL 1.1 -噪聲Noise 限制暴露時間Limit exposure time噪聲監測Noise monitoring 報警標志/通告Warning sign/notices屏蔽/防護欄Screens/barriers安裝消聲器/消音器Install noise muffler / d

2、amper 成套PPE耳塞+耳套Double PPE plugs + Ear muff 單個PPE耳塞Single PPE plugs低噪聲設備Low noise equipment1.2 - 溫度Temperature 限制暴露時間Limit exposure time溫度/濕度測量Temp/humidity ment.機械通風Forced ventilation個人防護設備（規定）PPE (specify)遮蔽/擋板Shield/Sheeting休息&恢復精力Rest & refreshment1.3 惡劣氣候Inclement Weather停止工作Stop work有系

3、帶的安全帽Helmet chin straps限制進入Restrict access個人防護設備（規定）PPE (specify)提供掩蔽處Shelter provided提前預報Forecast in Advance1.4 -振動Vibration 支架/減震器Supports/Dampers定期休息Periodic rest檢查設備靈敏度Check equip sensitivity1.5 - 挖掘Excavation 防護欄/照明Barriers/lights交通管制Traffic control道路封閉Road closure道路蓋板Road cover platesCSEP如果深度大

4、于1米CSEP if >1m depth 通道/出口/支護/斜坡Access/egress/shoring/slope1.6 - 照明Illumination/ Lighting 手提燈Hand lamps照明燈柱Floodlight towers危險區域設備Hazard area equipment臨時供電Temporary Power supply1.7 -滑坡/絆倒/墜落Slips / Trips / Falls 表面去除滑脂Degrease surface防滑涂層Non-slip coating墜落防護設備Fall arrestor表面不均勻的步履板Crawling boards

5、邊緣設扶手Edge handrails警告標志W(wǎng)arning signs危險警示帶Hazard tape warning安全設備位置Safe equip location防滑踏板Anti sleeping treads防護欄Barriers高處的固定纜繩Fix cables at height1.8 -壓力/貯存能量/高壓水噴射Pressure / Stored Energy / HP Water jetting泄壓/排放De-pressure/vent限制管線移動Limit line movement控制進入該區域Control area access使用認證的設備Use certified

6、 equip隔離Isolation個人防護設備（規定）PPE (specify)防護眼鏡和護目鏡Goggles and visor警告標志（通告）Warning sign (notice)1.9 -壓力試驗Pressure Testing.作業區域設置防護欄Barrier off area遵守安全工作程序Follow safe working procedure 在白天作業Work in Daylight Hours附加的PPE（規定）Additional PPE (specify) 控制作業區的人員Control Personnel in area排水Water drainage排出氣泡Ve

7、nt air pockets逐漸增加壓力Apply incremental pressure 1.10 -人工搬運Manual Handling使用機械搬運Use mechanical handling 卸去負荷Breakdown load人工搬運評估ManHandling Assessment 兩個以上人員抬起Two person or more to lift, 體力測試Fitness test個人防護設備，培訓PPE, training1.11 -粉塵Dust 保持地面濕潤Dampen Down抽吸Extraction個人防護設備（規定）PPE (specify)通風Ventilatio

8、n呼吸保護設備（規定）RPE (specify)設備接地以免靜電Earth equip to avoid static2.0 電氣的ELECTRICAL 2.1 - 靜電Static 設備接地Earthing equipment設備屏蔽接地Bonding of equipment泡沫地毯Foam blanket2.2 - 電壓Voltages 剩余電流裝置Residual Current Device設備檢查Equipment checks2.3 -使用電動工具Use of Power ToolsPAT試驗PAT Test危險區域Hazard Area 最大110V - 55V Max 110

9、 volt 55volt動火作業許可證Hot Work Permit工作位置有防護設施Guards in position適當?shù)腜PE Proper PPE2.4 -照明Illumination 手提燈Hand lamps保證供電Power supply secured照明燈塔Floodlight towers3.0 著火/爆炸FIRE/EXPLOSION 3.1 -起火源（明火，火花，表面溫度，摩擦）Ignition Source ( open flame, spark, surface temp, friction) 動火作業許可證Hot Work Permit惰性氣體Inert Atmo

10、sphere滅火器Fire Extinguishers火災探測器Fire Watcher消防水管Charged Hoses消防備用品Fire Standby水幕Water Curtain連續的氣體監測Continuous gas monitoring屏障/防火布Screens/Blankets3.2 - 氣瓶Gas Bottles 正確存放Correct storage連接軟管狀況Condition of pipes防回火裝置Flash back arrestor 使用前試驗Testing prior to use限制車輛進入Restrict vehicle access火花抑制裝置Spark

11、 arrestor定期氣體測試Periodic gas test連續的氣體試驗Continuous gas test正確的個人防護設備Correct PPE通風Ventilation 壓力表Gauges 鎖緊板手Lock spanners4.0 化學品與健康CHEMICALS & HEALTH 4.1 -與化學品或危險物品(煙霧、蒸汽、粉塵)接觸Exposure to Chemicals or Hazardous substances (fumes, vapour, dust)對健康有害物質控制的評估COSHH assessment就地排氣通風Local exhaust ventila

12、tion材料安全數據Material Safety Data 監控Surveillance monitoring個人防護設備（規定）PPE (specify)呼吸保護設備（規定）RPE (specify)呼吸裝置Breathing apparatus限制暴露時間Limit exposure密封罐車Sealed Skips作業區設置防護欄Barrier off area機械通風Forced ventilation培訓Training洗眼設施Eye Wash4.2 -化學品的存放Chemical Storage.就地通風Local ventilation對該區域筑堤隔開Bonded area警告標

13、志/通告Warning labels/Notices急救/洗眼設施First Aid/Eye Wash分類存放Store by categoryCOSHH評估COSHH Assessment材料安全數據單信息MSDS Info4.3 -電離輻射Ionization Radiation.查閱現場程序Consult site procedure4.4 -醫療健康Medical Fitness.由護士進行健康檢查Health check by nurse限制工作活動Limit work activities5.0 環境ENVIRONMENT 5.1 -氣味/散發Odours / Emissions.

14、關閉蒸汽Close Steam通知聯絡人員和HSEInform Liaison Officer HSE DEPT.空氣采樣Air Sampling控制該區域Control of Area5.2 -向地表水中排放Release to Surface Water System測試ph值Test ph value封閉易引起火災建筑物Close fire traps該區域筑堤Bund Area有真空罐備用Vac. tanker standby5.3 -固體/液體廢物Solid/Liquid Waste處理方式Disposal forms罐車/廢物箱Skips/drums堆放區Lay down area

15、廢物上貼標簽Waste labeled6.0 吊裝作業LIFTING OPERATIONS 6.1 -地下設施/電纜Underground Services / Cables檢查地基Check ground bearing 審視圖紙Drawings survey履帶式推土機Cats can起重機合格證Lift Certificate6.2 -地面狀況Ground condition鋼墊板Spreader mats用長吊臂起重機Use long reach crane6.3 可操縱性/擺動限制性Manoeuvrability /Slewing Restrictions防護欄Barriers增加起

16、重信號工Additional banksman安全巡邏員Security patrol6.4 -區域/進入/出口的控制Control of Area /Access / Egress道路封閉通告Road closure notice交通管制Traffic control起重信號工Banksman隔開起重區域Barrier off lift area設備離孔洞保持2米遠Keep plant 2m from hole標志/通告Signs/notices較小的負載Smaller load選擇合適的時間進行Choose proper time to perform 6.5 -在帶電設備上方吊裝Lift

17、 over liveequipment對意外情況作出計劃Contingency plan腳手架平臺Scaffold platform隔離設備Isolate equipment減小提升高度Reduce lift height6.6 -在電纜上方/下方吊裝Lift over/ under power cables豎立桿Erect vertical posts駕駛艙隔離Cab isolation警示帶Warning tape通知電氣部門Inform electrical dept6.7-照明/可見度Lighting/ visibility塔式照明Tower lights增加起重信號工Addition

18、al banksman6.8 -負載沒有標記Load Unmarked檢查記錄Check records與CAP聯絡Contact CAP 核對安全工作負載指示SWL indication check6.9 -人員升降Lifting of Personnel指定的升降設備Designated lift equip安全降落區Safe landing zone墜落防護吊繩Fall arrest harnesses與吊裝設備分開Equip lifted separately最大風速30米/小時Max wind speed 30mph與CAP聯絡Contact CAP只用認證合格的設備Certifie

19、d equip only對區域控制Control of area7.0 隔離ISOLATION 7.1 -未經證實的隔離Unproven isolation通風/排水Vent/drain氮氣吹掃N2 purge 開放蒸氣Open steam注水Waterfill檢查管線壓力Check line pressure個人防護設備PPE氣體試驗（見第11節）Gas Test (see Sect. 11)7.2 -斷開安全外殼/疏水口/下水道Breaking Containment /drains/sewers防護鏡/護目鏡Goggles/visor安全外殼/筑堤Containment/bund蓋住疏水

20、口Cover drains呼吸保護設備RPE呼吸器械Breathing apparatus個人防護設備PPE7.3 -不良的搬運方案Poor handling Arrangements起重機Crane臨時提升梁Temp lift beam人工搬運評估Manual handling assess.結構frame 7.4 -不合適的通道/出口Inadequate access /egress安裝臨時腳手架Erect temp scaffold清理平臺Clear platform增加起重信號工Additional banksmanaccess 提供2個通道Provide 2 routes of 8.

21、0 人員PEOPLE 8.1-學員/實習生(年青人)Trainee/ Apprentice(young persons)增加培訓Additional training不斷的監督Constant supervision作業危險評估Task risk assessment限制體力活動Limit physical activity8.2 - 能力Competency 評估合同細節Evaluate contract details 證書檢查Certification check附加作業培訓Additional task training不斷的監督Constant supervision精通JHA Fa

22、miliarity with JHA8.3 -對其他工作/人員的影響Impact of other Work /PeopleJHA/許可證審核JHA/Permit review 用防護欄控制區域Control of area by barrier審核其他工作Review of other work現場檢查和監督Site visit and monitoring9.0 限制空間的進入CONFINED SPACE ENTRY 9.1 缺氧Oxygen Deficiency O2氧氣監測/連續呼吸器Monitor O2/continuous Breathing apparatus不需要呼吸器即可進入

23、No BA entry 19.5<O2 <20.5% 如19.5<O2< 20.5%, 如果O2 <19.5%應使用專業呼吸器Specialist BA if O2 <19.5% 通風Ventilation9.2 -可燃物品的使用Use of flammable substances通風Ventilation 氣體/低爆炸限監視Gas/LEL monitoring個人保護設備/呼吸保護設備PPE/RPE CS為最低量Min quantity in CSCOSHH的評估COSHH Assessments 使用防爆設備和消防設備Use EX equipment,

24、 fire fighting equipment儲存在外邊External Storage9.3 -危險物/氣體的進入Ingress of hazard Substances/ gases遮蓋當?shù)氐呐潘疁螩over local drains連續空氣監測Continuous air monitor -ring 防止排放Protect from exhaust9.4 - 產生有毒煙霧/剩余物Toxic fumes generated/residue 通風Ventilation 呼吸器械Breathing apparatus個人防護設備/呼吸保護設備PPE/RPE 氣體監測/連續Gas monito

25、ring/ continuous泥漿分析Sludge analysis 9.5 - 灰塵Dust 監視空氣中的灰塵Monitor dust in air就地排氣通風Local exhaust ventilationCOSHH評估COSHH Assessment 呼吸保護設備（規定）RPE (specify) 加強空氣通風Forced air ventilation使地面保持濕潤Dampen down9.6 -身體限制Physical restrictions限制個人嗅聞Restrict personnel nose機械通風Forced ventilation 避免內部儲存Avoid inter

26、nal storage限制物體移動Isolate free moving objects 減震帽Bump caps 9.7 溫度/濕度Temperature /Humidity 溫濕度測量Temp humidity measures限制暴露時間Limit exposure time間斷性休息Periodic breaks 個人防護設備/呼吸保護器PPE/RPE 強制通風Forced ventilation 人員的交替Rotation of personnel最大攝氏40度限制Max 40deg C limit9.8 -靜電/限制導體地點Static/Restrict Conductive lo

27、cation設備接地Equipment earthed和電力部門商議RCDs低壓設備（<12V）Low voltage equip (<12v) Consult elec dept9.9 -應急安排Emergency arrangements 應急道路通暢Emergency routes clear道路交通管制Road traffic control消防車就緒Fire tender standby安全帶/救生索Harness/lifeline安全部門的指導Safety Dept Advised有救援隊伍Rescue Team available救護車備用Ambulance stan

28、dby計劃道路路線Plan routing of lines區域控制Control of Area 9.10 -進/出口Access/ Egress 臨時平臺Temporary platform防護欄/標志Barriers/signs 露天保護設施Weather protection良好的照明Good lighting 手電筒Hand Torch 個人照明Personal Lights 救生索Lifeline 9.11-通信/進入控制Communication Entry ControlVEC監護人Standby man 道路看守人無Manway watcher - no無線電Radio 火災

29、探測器Fire watchers 警笛/霧號/哨子Klaxton/foghorn/whistle9.12 -限制搬運Restricted handling拆卸設備Dismantle equipment人工搬運評估Man handling assessment 嚙合裝置Mech devices 提供“A”框架Provide A frame9.13 - 放射源Radioactive sources 參考現場程序Refer to Site Procedure警告標記Warning signs防護欄/通告Barriers / notices工作許可證Permit to work 個人防護設備PPE 9

30、.14 - 絕緣Insulation 參考現場程序Refer to Site Procedure污染物掩蔽Containment shelter空氣監測Air monitoring 個人防護設備/呼吸保護設備PPE/RPE 9.15 -照明 Lighting 標識危險區域Haz area certified低電壓-24伏Low voltage - 24 volt閃光燈Snap lights 泛光照明Flood lights 接地Earthed 9.16 -著火/爆炸explosion / Fire 減少塵土的累積Eliminate dust build up動火許可證Hot work perm

31、it 連續氣體監測Continuous gas testing火花污染Spark containment火災探測器Fire watchers 防止弧光眼的隔板Screens against arc eye 滅火器Fire extinguishers 消防水管Charged water hose9.17 -涉及其他的影響Impact on others.煙氣排放方案Fumes plan 工作區域隔離Segregation, of work areas 許可證審核Permit Review 進入容器/監護人Vessel entry/standby9.18 -穿戴呼吸器進入.Entry under BA 只有經過呼吸器使用培訓的人員BA trained persons only作業許可證Permit To Work 10.0 高空作業WORKING AT HEIGHTS 10.1 -高空墜落Falls from h