消防、救生設備登記檢查養護記錄簿課件

1、消 防 設 備THE CONDITION OF FIRE-FIGHTING EQUIPMENT水滅火系統系統設備名稱型號數量自動報警系統探火報警器型號主消防泵其他水泵探測器類型水帶數量水槍生產廠消防栓出廠年月國際通岸接頭應急消防水泵固定滅火系統鋼 瓶（容器）容量數量總量被保護處所瓶 頭 閥型式接口口徑泡沫滅火系統泡沫液柜容量泡沫液型號生產廠甲板泡沫炮數量大型滅火器名 稱型 號數量存放位置應配實有泡沫滅火器便攜式泡沫噴槍CO2滅火器干粉滅火器備注消 防 設 備THE CONDITION OF FIRE-FIGHTING EQUIPMENT手提式滅火器滅火器名稱型號數 量存放位置應配實用泡沫滅火器

2、CO2滅火器干粉滅火器1211滅火器消防員裝備名稱規格型號數 量存放位置配備實有防護衣（鋁箔衣）長統靴手套（絕緣）頭盔手斧防爆燈空氣呼吸器耐火救生繩其他消防工具名稱規格型號數 量存放位置應配實有太平斧撬棒鐵鉤沙箱水桶備注救 生 設 備THE CONDITION OF LIFESAVING EQUIPMENT救生艇種類數量材料定員尺寸吊艇鋼絲換新/調頭日期反光帶開敞式艇封閉式艇尾拋式艇救生筏型號數量檢驗日期檢驗日期檢驗日期檢驗日期檢驗日期靜水壓力釋放器備注救 生 設 備THE CONDITION OF LIFESAVING EQUIPMENT救生艇信號名稱生產廠家有效期數量生產日期生產日期生產日

3、期紅光降落傘紅光火焰橙色煙霧駕駛臺信號紅光降落傘帶燈煙霧信號拋繩器個人救生器材救生服救生圈救生圈燈救生衣燈救生衣救生艇有時效物品名稱生產日期有效期數量生產日期有效期數量急救藥箱暈船藥片口糧（袋）淡水（升）備注備 品 登 記 表SPARE PARTS RECORD序名稱型號數量生產日期有效期存放位置備注備 品 登 記 表SPARE PARTS RECORD序名稱型號數量生產日期有效期存放位置備注船長、大副查閱記錄MASTER、C/O CHECK RECORD大副查閱意見記錄日期大副查閱意見記錄日期船長查閱意見記錄日期三 副 交 接 記 錄3 RD OFFICER CHANGE RECORD日 期

4、交班三副簽 字接班三副簽 字備 注船長簽字1 消防設備檢查、測試和養護的周期和內容Inspection and maintenance of fire-fighting equipment序No.種類Description檢查周期Duratiom檢查內容和要求Requirements of inspectioms1主消防泵Main fire pump每周weekly主消防泵的試驗Test of fire pump2應急消防泵Emergency fire pump每周weekly應急消防泵及其艙室的檢查和試驗Inspection and test of emergency fire pump a

5、nd compartment3消防總管Fire main每月monthly消防總管的檢查和試驗Inspection and test of fire main4消防栓、消防皮龍水槍Hydrants,hose and nozzles每周weekly甲板、住所和機艙內的消防皮龍箱的檢查General inspection of fire cabinets on deck,in the accommodation and in the machinery space5手提式滅火器（泡沫、CO2、干粉）和手提式泡沫發生器Portable fire extinguisher(foam,CO2,dry p

6、owder) and portable foam applicator units每月monthly根據防火布置圖檢查每種型號的手提式滅火器數量Checking the number of portable fire extinguishers of each type according to the fire control plan6防火門，防火閘，逃生路線，天窗，探火裝置和通用報警Fire doors,fire dampers,means of escape,skyligjts,fire detection equipment and general alarm每周weekly居住區，

7、各種甲板和機艙的總體檢查，尤其應注意防火門，防火閘，逃生路線，天窗，手提式和推車式滅火器，隨機測試一些探火裝置并試驗通用報警General inspection of accommodation,various decks and machinery spaces with particular attention to fire doors,fire dampers,means of escape,skylights and portable and semi-portable fire extinguishers.Test at random of a number of fire det

8、ectors and test general alarm7探火裝置Fire detection equipment每季quarterly徹底試驗整個裝置和探測頭Complete test of the whole installation detectors8國際通岸接頭International Shore Connection每月monthly檢查通岸接頭Checking the shore connection9消防員裝備Fireman's outfit每月monthly檢查消防員裝備Checking the fireman's outfit10固定1211/CO2滅火

9、系統Fixed 1211/CO2 fire extinguishing system每季quarterly檢查和試驗固定1211/CO2滅火系統Inspection and test of fixed 1211/CO2 fire extinguishing system11固定式泡沫滅火系統Fixed foam fire extinguishing system每季quarterly檢查和試驗泡沫滅火系統Inspection and test of fixed foam fire extinguishing system12油漆間的消防設施Fire extinguishing arrangem

10、ent in paint locker每季quarterly油漆間消防設施的檢查Inspection of the fire extinguishing arrangement in paint locker 13惰性氣體系統IGS每季quarterly惰性氣體系統的檢查Inspection of the IGS1.1 消防泵及其消防皮龍等檢查細節（每周）Inspection details of fire pumps and hoses etc.(weekly)序No.種類Descripion檢查內容和要求Requirements of inspections1主消防泵Main fire p

11、ump消防泵工作是否正常，保持合適的壓力，壓力表正常，原動機處于良好狀態Checking that the pump operates is in good order, the proper pressure is maintained,the pressure gauges are in order,the prime mover is in good condition.2應急消防泵Emergency fire pump檢查原動機的啟動和運轉，檢查為冷啟動配備的加熱裝置，檢查專用燃油是否足夠供泵在最大負荷下運行至少3小時，在機艙外是否儲備足夠燃料供泵再運行15小時。檢查啟動系統和/或止回

12、閥的運行狀況。檢查應急消防泵處所：泵處所四周是否被隔熱，如與機艙直接相通，是否設有氣閘或遠控水密門且工作正常。Checking the starting and operating condition of the prime mover. Checking the heating arrangement for cold starting.Checking that the quantity of the designated fuel is sufficient to run the pump on full road for at least 3 hours.Checking that

13、there is a sufficient reserve of fuel outside the main machinery space to run the pump for an additional 15 hours.Checking the operating condition of the priming system and/or non return valve,the operating condition of the isolating valves and cocks.Checking the operating condition of the pump at r

14、equirede pressure(for at least 20minutes).Checking the space containing the emergency fire pump.Checking that the boundaries of the space are insulated,in case of direct access from the machinery spaces,checking that there is suitable airlock or remote control watertight door provided and in operati

15、ng order.3消防栓Hydrants是否有足夠的消防栓和皮龍接頭，開關正常Checking wether there are adequate hydrants and hose couplings. Valves are in operating condition4皮龍和皮龍箱Hoses and fire cabinets皮龍箱的鉸鏈?zhǔn)欠裾?，每個皮龍箱均配備扳手，皮龍存放位置是否合適、數量是否符合防火控制圖的要求，皮龍密封圈是否正常The hinges of the cabinets in good condition.Spanners provided in each fire

16、cabinet. All hoses in place and the number of hoses in compliance with the fire control plan.The hoses ring seals in good condition.5水槍Nozzles消防皮龍附近是否有水槍，是否所有水槍均處于工作狀態，水槍數量足夠，兩用水槍（噴霧/水柱）是否有選擇（關閉）閥Provided in the vicinity of the fire hose.All nozzles in operating condition. Adequacy of nozzles. All n

17、ozzles of a dual-purpose type（spray/jet）incorporating with a shut-off.6防火門Fire doors檢查是否開關自如無阻礙，自動關閉門沒綁住或用鉤子固定，遠控操作正常（如有裝設）Checking that they operate satisfactorily and are not abstructed. Checking that self-closing doors are not lashed or hooked. Checking the remote operation is in order.1.1 消防泵及其消

18、防皮龍等檢查細節（每周）Inspection details of fire pumps and hoses etc.(weekly)序No.種類Description檢查內容和要求Requirements of inspections7防火閘Fire dampers檢查關閉裝置，包括自動關閉裝置（如有裝設）是否處于正常狀況Checking that closing arrangements,including automatic means of closure when fitted are in operational condition.8天窗Skylights檢查關閉裝置包括遠控和自

19、動關閉裝置（如有裝設）是否處于正常狀況Checking that closing arrangements including remote control and automatic means of closure when fitted are in operational condition.9逃生路線Means of escape檢查逃生路線是否無障礙物，梯子踏板和扶手是否處于良好狀況，照明是否正常Checking that the escapes are unobstructed,that steps and handrails are in good order and that

20、 illuminating is operating properly.10滅火器Fire extinguisher檢查滅火器是否放置在指定位置，其外部處于滿意狀況Checking that they are located in their assigned places, in external satisfactory condition.1.1.1 消防泵及其消防皮龍等檢查測試和養護記錄（每周）Record of inspection test and maintenance of fire pumps and hose etc.(weekly)檢查日期檢查，測試養護情況記錄檢查人簽名

21、1.1.1 消防泵及其消防皮龍等檢查測試和養護記錄（每周）Record of inspection test and maintenance of fire pumps and hose etc.(weekly)檢查日期檢查，測試養護情況記錄檢查人簽名1.1.1 消防泵及其消防皮龍等檢查測試和養護記錄（每周）Record of inspection test and maintenance of fire pumps and hose etc.(weekly)檢查日期檢查，測試養護情況記錄檢查人簽名1.1.1 消防泵及其消防皮龍等檢查測試和養護記錄（每周）Record of inspectio

22、n test and maintenance of fire pumps and hose etc.(weekly)檢查日期檢查，測試養護情況記錄檢查人簽名1.1.1 消防泵及其消防皮龍等檢查測試和養護記錄（每周）Record of inspection test and maintenance of fire pumps and hose etc.(weekly)檢查日期檢查，測試養護情況記錄檢查人簽名1.1.1 消防泵及其消防皮龍等檢查測試和養護記錄（每周）Record of inspection test and maintenance of fire pumps and hose et

23、c.(weekly)檢查日期檢查，測試養護情況記錄檢查人簽名1.1.1 消防泵及其消防皮龍等檢查測試和養護記錄（每周）Record of inspection test and maintenance of fire pumps and hose etc.(weekly)檢查日期檢查，測試養護情況記錄檢查人簽名1.1.1 消防泵及其消防皮龍等檢查測試和養護記錄（每周）Record of inspection test and maintenance of fire pumps and hose etc.(weekly)檢查日期檢查，測試養護情況記錄檢查人簽名1.2 消防總管及其存放裝置檢查細節

24、（每月）Inspection details of fire main and other (monthly)序No.種類Description檢查內容和要求Requirements of inspections1消防總管Fire main在有壓力下檢查和用小錘試聽消防總管，特別注意到：污泥易積聚的地方、易腐蝕的地方，檢查通向機艙的消防總管上的截止閥是否正常Inspection and hammer testing of the fire main under pressure,with particular attention to: areas where dirt may accumul

25、ate,areas prone to corrosion,valves isolating the fire main section in the machinery space from the other sections of the fire main in operating order.2手提滅火器Portable fire extinguishers根據防火控制圖檢查每種型號的滅火器數量，位置，清潔保養，檢查存放容器是否處于良好狀況，無腐蝕，能否立即投入使用，檢查有效期，記錄在登記卡上Checking the number,location and maintenance of

26、 portable fire extinguishers of each type according to the fire control plan.Checking that cylinders are in good condition,without serious corrosion,ready for use.Checking the validity date and recorded on the labels.3國際通岸接頭International shore connection檢查是否配有帶有標準法蘭盤尺寸的通岸接頭，四套螺栓和螺母，一個密封圈Checking the

27、 shore connection with standard dimension flange,four sets of bolts and nuts,one gasket packing are available on board.4消防員裝備Fireman's outfit檢查是否配有四套裝備，根據防火控制圖檢查其存放場所是否處于正常狀態；檢查防護服、長統靴、手套、硬頭盔、安全帶、電池防爆燈、手斧等；檢查帶有防煙盔或防煙罩的儲壓式呼吸器，200%備用空氣瓶且充足氣。每一空氣呼吸器是否有足夠長度的耐火救生繩。Checking the four sets of fireman

28、9;s outfit are on board.Checking that the stowage is in good order according to the fire control plan.Checking the protective clothing,boots,gloves,helmet,belt,electric safe lamp,axe.Checking the self-contained compressed air breathing apparatus with a smoke helmet or smoke mask and with 200% spare

29、air cylinders full charged.Checking that there is a fireproof lifeline of sufficient length for each breathing apparatus.5應急逃生呼吸器Emergency escape breathing devices(EEBD)配備數量是否符合要求（中國船檢要求配5套，巴拿馬船籍配備7套）外觀是否清潔，完好，壓力是否正常。The number of EEBD onboard meets the requirement (CCS requirement:5 sets,panama Mar

30、itime Authorities requirement:7sets),and if their externals are clean and intact,the pressure is normal.1.2.1 消防總管等檢查養護記錄（每月）Record of inspection test and maintenance of fire main etc.(monthly)檢查日期檢查，測試養護情況記錄檢查人簽名1.2.1 消防總管等檢查養護記錄（每月）Record of inspection test and maintenance of fire main etc.(monthl

31、y)檢查日期檢查，測試養護情況記錄檢查人簽名1.2.1 消防總管等檢查養護記錄（每月）Record of inspection test and maintenance of fire main etc.(monthly)檢查日期檢查，測試養護情況記錄檢查人簽名1.2.1 消防總管等檢查養護記錄（每月）Record of inspection test and maintenance of fire main etc.(monthly)檢查日期檢查，測試養護情況記錄檢查人簽名1.3 消防固定滅火系統及其存放裝置檢查細節（每季）Inspection details of fixed fire e

32、xtinguishing system etc.(quarterly)序No.種類Description檢查內容和要求Requirements of inspections1固定滅火系統（氣體）Fixed fire extinguishing system(Gas)檢查放置固定滅火系統場所是否標志合適并處于良好狀態，沒放置笨重物品，操作須知必須永久顯示，氣體鋼瓶完整且放置合適，氣體鋼瓶的外部狀況無嚴重腐蝕，檢查下次鋼瓶的稱重日期、管系暢通試驗日期、鋼瓶壓力測試日期（兩年一次），檢查管系是否處于良好狀態且無嚴重腐蝕：試驗氣體釋放時的聲音報警是否正常。Checking that the fixed

33、 fire extinguishing room is properly marked and in good condition,free of stored heavy articles.The operating instructions must be permanently posted. The gas cylinders are complete and properly stowed.The external condition of gas cylinders in free of serious corrosion.Checking the next due weighin

34、g date of the cylinders,the next due servicing date of the piping system and the next due pressure testing of the cylinders (at least once every 2 years). Checking that the pipe lines are in good order and that there is no heavy corrosion. Testing the audible alarm for the release of gas.2水滅火系統Fixed

35、 fire extinguishing system(Water)檢查噴水系統的操作須知是否永久顯示，檢查給水泵萬一系統壓力下降的自動啟動的操作要領，檢查管系是否處于良好狀態，有腐蝕或滲漏跡象，機艙外部的分配器處于良好控制狀態，隨機檢查噴嘴。Checking that the operating instructions of the water spray system are permanently posted. Checking the operating order of the water feeding pump including its automatic starting

36、in case of the pressure drops in the system. Checking that the pipelines are in good condition,showing neither trace of corrosion nor leakage. Checking that the distribution valves outside the machinery space are in operating condition. Inspect the water spray nozzles at random.3泡沫滅火系統Foam fire exti

37、nguishing system檢查泡沫柜的液位顯示儀是否完好，藥劑是否滲漏，是否在有效期內，操作程序在明顯處永久顯示。Checking that the liquid level indicator of the foam tank is in good condition,without leakage of liquid.Checking the validity date of liquid.Operating instruction permanently posted on the obvious place.4油漆間滅火系統Fire extinguishing arrangeme

38、nt in paint locker檢查消防系統是否處于良好狀態Checking that the fire extinguishing system is in good condition5惰性氣體系統IGS檢查操作是否滿意，檢查控制板上的報警是否工作正常Checking that operation is in satisfactory condition. Checking that the alarm on the control panel works in order.1.3.1 消防固定滅火系統及其存放裝置檢查記錄（每季）Record of inspection test an

39、d maintenance offixed fire extinguishing system etc.(quarterly)檢查日期檢查，測試養護情況記錄檢查人簽名1.3.1 消防固定滅火系統及其存放裝置檢查記錄（每季）Record of inspection test and maintenance offixed fire extinguishing system etc.(quarterly)檢查日期檢查，測試養護情況記錄檢查人簽名2 救生設備檢查、測試和養護的周期和內容Inspection and maintenance of lifesaving equipment序No.種類De

40、scription檢查周期Duration檢查內容和要求Requirements of inspections1救生艇和救助艇及其脫鉤裝置Lifeboats,rescue,boats and their launching arrangement每周weekly救生艇和救助艇及脫鉤裝置的目視檢查Visual inspection of lifeboards,rescue boat and release gear.2救生艇/救助艇的發動機運轉試驗Operation test of lifeboats and rescue boat engine3救生艇/救助艇從其存放位置移出試驗Move te

41、st of lifeboats and rescue boat from stowing position.4救生艇和救助艇設備和屬具Lifeboat and rescue boats equipments and articles每月monthly救生艇和救助艇內設備和屬具檢查Inspection of equipments and articles of lifeboat and rescue boats5救生艇和救助艇施放裝置Lifeboat and rescue boat launching arrangements每月monthly救生艇和救助艇施放裝置的總體檢查Thorough i

42、nspection of lifeboat and rescue boat launching arrangements6救生筏及其存放位置Life-rafts and stowing position每周weekly救生筏及其存放位置的外觀檢查Visual inspection of life-rafts their stowing position7個人救生器材Personal lifesaving appliances每月monthly 救生衣，救生服和保溫用具的檢查Inspections of lifejackets,immersion suits and thermal protec

43、tive aids8救生圈Lifebuoys每月monthly救生圈及其存放位置檢查Inspection of lifebuoys and their stowing position.9煙火信號Pyrotechnics每月monthly煙火信號數量和有效期的檢查（駕駛臺）Inspection of numbers and validity of pyrotechnics(at bridge)2.1 救生艇和救助艇檢查細節（每周）Inspection details of lifeboatsand rescue boats(weekly)序No.名稱Item檢查內容和要求Requirement

44、s of inspection1救生艇和救助艇外觀Lifeboats and rescue boat檢查艇體內外部的狀況是否良好Checking the condition of hull inside and outside2檢查艇兩邊的救生握索是否良好Checking that grab lines on both side are in order3檢查艇兩邊的舭龍骨欄桿狀況是否良好Checking the bilge keei rails on both side4檢查艇體的反光帶狀況是否良好Checking the retro-reflective tapes on hull5檢查救生艇和救助艇的標志Checking the lifeboats and rescue boats marking6救生艇和救助艇內部裝置Lifeboats and rescue boat檢查所有艙蓋以及墊片，并進行操作試驗Check for all hatches and gaskets,and take easy oper